Club 80-90 Forums

What's the length/height of standard front and rear springs please?

It merely a thought at the moment but, I’ve bought an accident damaged TT for the interior for my own car which was a little shabby.
I essentially...

I had water in the fuel tank due to a perished seal. The van was running rough until it stopped completely. That was 2 months ago. 
Today I removed...

Sorry if this is a daft question. My new speedo cap (square hole in centre) has fell off never to be seen again after only doing about 5 miles. It...

Hiya, New here!

Not sure if this is the right place for this or not?  I've just got an 85 Westy High Top, and love it, except for sleeping in the...

Pulling off the A30 yesterday on an uphill gradient I suddenly lost all gears. With the engine off went into gear easily but stalled when I tried to...

Hi guys,

Has this happend to anyone?? went to check coolant pipes before going away this week end and pulling one pipe unleashed hell..

this...

(Diesel Syncro)

How much play should there be in the gear selection rod (long section) going through the T-section into the box? At a guess mine has...

Can’t work this one out. Engine has twin Webber carbs. Valve lifters replaced 1k miles ago because of same fault. Head replaced because it dropped a...

Hi can anyone help I'm a bit thick when it comes to electricity! I've got a cf6 zig unit im my holdsworth and an invertor which is has 2 plug sockets...

Long shot. I need the shaft out of a 1990 T25 1.6 JX TD injection pump. Anyone know where to find one?

Last year I happened upon a N.O.S. VAG branded alarm from the 80s.

Part Number :- 111999155A / 111 999 155A for Volkswagen and Audi cars.
(No...

Has anyone fitted Alfa Romeo 147 front seats into a Vanagon or T3/T25 Single cab or Doka, WITHOUT removing the original VW seat tracks on the truck?...

Anyone using a Powerspark 034 SVDA distributor on a 2.0 L petrol CU engine ? Wondering what timing figures you're using ?

Hi all, 

I need to replace the back support part of the back seat in my baby. Im guessing it is the original seat/bed as the cushion is going...

My auto box was running great yesterday, took it out today for 6 miles and started slipping, now only goes on reverse and no forward gears engage....

1984 Holdworth pop top 1.9 petrol
Hi Everyone, looks like a typical holiday getaway weather coming our way, so out in vans not so great.
I am asking...

Hi - I have a 1983 Vanagon 2l CU and it has a single Weber DFEV 32/36 conversion installed. I’m going to take it off and give it a full rebuild and...

Just need a mechanic to get me over the line with my resto.
84 twin slider 1.9 DG.
New clutch fitted can’t disengage when I depress the pedal.
Tried...

My brake pedal has gone hard! So I’ve done the usual checks. I unplugged the vacuum pipe from the servo and started the engine. I wasn’t getting...

Can anyone suggest a garage in the Bedfordshire area to sort out my coolant leaking problem?

Hi, I am really new to this club, and also new to posting on forums. Great club!
We live in Kent and own a 1986 T25, high top which we call Bumble....

Thought I would take off the Carb on my ct engine and service/rebuild it. ( all of a sudden I had an issue with it whilst driving under load it would...

Hi

Will a starter motor from a 1982 1.6  diesel engine fit a 1987 1.7 diesel engine ?

Suppliers show just two  different part number for all...

Hi,

I am looking to buy a Heater Matrix for my watercooled T25 Petrol. Cant get hold of part number: 251265313C

I found this one which has part...

Has anyone successfully fitted a set of opening quaterlights from NLAV? I have a set and I am struggling to fit them correctly.

My 1.9 converted (AAZ I think) has some issues when it starts. Lots of blue smoke, next to none when idling, not as bad but some when revved after a...

Long story short, I've just remembered I have some seats in the loft which came out of an old van...

Does anyone know anyone who has fitted caddy 2k...

I'm currently undertaking a 1.6td jx rebuild and the vw manual says that amv 188 100.02 is required for the piston oil squirters.
Not much info on...

Hi,

Putting dual Weber carbs on 1600 CT engine. I am struggling how to link my vans existing throttle cable to the hex bar linkage between my Weber...

Hi
Does anyone know who does 3 piece cab mats for the 1.6TD shell?
I saw these which I liked but I'm unable to get hold of Bob to ask if they are...

Apologies if asked before, i've been trawling but can't find much specifics on this.

Van is a twin slider (no full length kitchen), Full width RnR...

Hi Everyone hope you are all doing well, can someone please help,

I have removed the fridge and also the rear heater in my late T25 but for the life...

Our usual mechanic has just gone off on long term sick and we need to find someone nearby to take care of our 1991 1.9 Diesel Holdsworth Villa 3....

Can someone tell me why some Devon full length elevating roofs have 3 struts, one at the front and two at the back as mine has and yet some roofs...

Hi, I need to replace the gas struts on my Devon poptop I have tried taking measurements but they all vary in length slightly probably because they...

Just checking new server...

Hi all

Welcome to summer! 

I was out in Saoirse, my bus, yesterday, going up and down a lot of hills. She could charge up steep hills at a good...

Hi all, does any one have a spare Servo and master cylinder lying around they could take some measurements from for me, mainly the distance between...

Doing checks on van, coolant, oil levels etc. Oil level was below minimum mark, thought that can't be right as the engine would have been clattering...

I have a new tank fitted to the van. If you brim the tank, it leaks through the rubber seal between the breather pipe and top of the tank - part 6 on...

Owned my t25 for 17 years converted to day van shortly after purchasing and used ever since
On the logbook it still has minibus and when you go dvla...

Guys I have an lt50 horse.box I thought the water warning light was indicating low water So topped her up but was full The light stayed on I filled...

So the PO bought a Pict 34 4 to replace the 5, not sure if this was deliberate or a mistake, but the guy he paid to put it in has got it in but at...

Can anyone here recommend a garage that does full restorations. Ideally in Scotland but to get it done properly I'll go anywhere in the UK

I bought one of these years ago, genuine VAG stock but I am struggling to identify the Webasto model number to get a wiring or connection diagram?...

Hi, I’ve just replaced the N75 valve on our 1z tdi conversion - which was done professionally five years ago - and discovered that the hose coming...

Hi all, new to this so please bare with me 😳
I have a 1983 T25 Viking1.6 diesel conversion that's being dismembered and attempting to restore, wheels...

I have a 1Y engine fitted in my bus and its time for cambelt change. I don't know what the donor vehicle was so am asking if all 1y engines have the...

Hi all

I have electric power steering in my van with a smaller Mk2 Golf steering wheel along with saab seats which is good and knee clearance is...