Mechanical

Moderators: User administrators, Moderators

7523 topics

Page 124 of 151
- Jump to page:
Previous
1
…
122
123
124
125
126
…
151
Next

Most liked posts	Author	Posted	Liked	Forum
Brake Pipe Bolt Seized	maxstu	Yesterday, 15:57	2 times this week	Mechanical
2.0L CU Aircooled. Bad oil leak after running a 500 mile trip overfilled	Lord-won't-you	Yesterday, 09:52	2 times this week	Mechanical

Topics

Replies

Views

Last post

Gearbox oil leak

Last post by dust « 15 Jun 2015, 08:56
Replies: 6
by dust » 11 Jun 2015, 20:58

Hi, I have recently bought a 1985 Transporter, 1.9TD (engine taken from a Golf).

A few weeks ago I noticed some oil leaking, I took it to a Garage...

6 Replies

2427 Views

Last post by dust
15 Jun 2015, 08:56
tune up

Last post by westie37 « 15 Jun 2015, 08:41

by westie37 » 15 Jun 2015, 08:41

anybody know of a good tune up garage in the FIFE area van no idleing

0 Replies

1622 Views

Last post by westie37
15 Jun 2015, 08:41
Sensor on gearbox. What does it do? Mines not connected.

Last post by clift_d « 14 Jun 2015, 22:37
Replies: 6
by mines a money pit » 14 Jun 2015, 18:08

Changing my clutch slave cylinder today and noticed a sensor on the left side of the gearbox with 2 spade connections. However there is nothing...

6 Replies

1643 Views

Last post by clift_d
14 Jun 2015, 22:37
jx sump and oil filler gasket replacement

Last post by hulky « 14 Jun 2015, 18:04
Replies: 4
by hulky » 14 Jun 2015, 17:39

Hi

looking at doing these gaskets over next couple days.Any tips on what to do and what not to do ? before i start and do something wrong.

thanks...

4 Replies

1083 Views

Last post by hulky
14 Jun 2015, 18:04
VW Camper Specialists in Leicestershire

Last post by cristoffa « 14 Jun 2015, 15:43
Replies: 6
by cristoffa » 08 Jun 2015, 19:00

Hi all,

I have a 1983 Automatic which I would like to find a reliable local VW specialist to look after.

Does anyone have any recommendations for a...

6 Replies

3196 Views

Last post by cristoffa
14 Jun 2015, 15:43
Upper ball joint removal - tricky or not?!

Last post by chuggers72 « 14 Jun 2015, 14:39
Replies: 24
by chuggers72 » 06 Jun 2015, 18:55
1

2
Bit of advice please !

I'm lowering the ol' gal and on the final front n/s. I need to replace the upper ball joint as the boot is well past it. I've...
24 Replies

8751 Views

Last post by chuggers72
14 Jun 2015, 14:39
Replacing cylinder head water jacket - some advice please

Last post by itchyfeet « 14 Jun 2015, 11:52
Replies: 5
by hughzt » 13 Jun 2015, 12:07

I've just removed the right-hand head off my 2.1 petrol engine in order to replace that pesky leaking water jacket seal. Whilst removing the head the...

5 Replies

2250 Views

Last post by itchyfeet
14 Jun 2015, 11:52
Suspected waterpump failure 1990 petrol 2.1

Last post by ghost123uk « 14 Jun 2015, 06:53
Replies: 2
by bruceinedinburgh » 13 Jun 2015, 19:26

Hello there
Our wee holiday was cut short when we left N Berwick this morning and the temp warning light began flashing with the needle in centre of...

2 Replies

1828 Views

Last post by ghost123uk
14 Jun 2015, 06:53
Oil temp and CHT gauges...which to buy?

Last post by paulandchez « 13 Jun 2015, 20:45

by paulandchez » 13 Jun 2015, 20:45

I'm well on with my engine build, and want to fit oil temp and CHT gauges. I've read the VDO ones can be quite iffy for accuracy, so was looking at...

0 Replies

1699 Views

Last post by paulandchez
13 Jun 2015, 20:45
Newbie help

Last post by Dazco « 13 Jun 2015, 20:20
Replies: 3
by Rayzor » 13 Jun 2015, 17:57

Hi I have just purchased my first Camper a T25 Holdsworth , it needs some TLC . I live in the Romford / Essex area can anyone recommend some...

3 Replies

1153 Views

Last post by Dazco
13 Jun 2015, 20:20
Petrol smell whilst driving

Last post by marlinowner « 13 Jun 2015, 10:09
Replies: 5
by kevcorks » 13 Jun 2015, 08:22

So, Doreen passed her MOT after carrying out quite a fair bit of work on her, over the moon.
decided to go for a bit of a run up the lakes as it was...

5 Replies

2181 Views

Last post by marlinowner
13 Jun 2015, 10:09
AAZ engine starting behaviour.. Lumpy, smoky. Fuel pump?

Last post by FRAJ « 30 Oct 2015, 18:17
Replies: 5
by FRAJ » 13 Jun 2015, 07:59

Hello all. After reading this forum for a while I finally joined...
I have a t25 with aaz diesel and a question about what could be causing a...

5 Replies

4091 Views

Last post by FRAJ
30 Oct 2015, 18:17
t25 accelerator getting jammed on full revs

Last post by Fudgy666 « 12 Jun 2015, 09:54
Replies: 9
by angelabbie » 10 Jun 2015, 08:31

hi am new here so please bare with me. I know nothing about my camper van but guess I am about to learn. The accelerator got jammed on full revs as I...

9 Replies

5889 Views

Last post by Fudgy666
12 Jun 2015, 09:54
2.0 Aircooled flexi pipe exchanger to central alternative?

Last post by dugcati « 12 Jun 2015, 09:14

by dugcati » 12 Jun 2015, 09:14

Anyone know what and who can supply decent alternatives for parts 6 and 7 on here? Pipe 7 on my bus is wrecked (age/weather and heat) but I'm not...

0 Replies

1983 Views

Last post by dugcati
12 Jun 2015, 09:14
2e3 refurb info

Last post by itchyfeet « 12 Jun 2015, 08:29
Replies: 1
by PeeSG » 11 Jun 2015, 17:27

Got the rebuild kit for the t25 carb - 2e3 19mm. Can't find any info on how to refurb it anywhere. Just seperated top half from bottom half of body....

1 Replies

1024 Views

Last post by itchyfeet
12 Jun 2015, 08:29
Un identified corrosion

Last post by windydubber « 12 Jun 2015, 07:58
Replies: 4
by windydubber » 11 Jun 2015, 20:20

Can anyone identify this part that is corroded? And how worried do I need to be? Cheers.

4 Replies

1353 Views

Last post by windydubber
12 Jun 2015, 07:58
Engine revs slow to drop down

Last post by nordberg « 12 Jun 2015, 06:27
Replies: 33
by killerme » 16 Jul 2014, 17:34
1

2

3
Hi - can anyone suggest a possible explanation for this? I have a turbo diesel 1600 1988 T25 (the engine was changed to diesel sometime in Germany...
33 Replies

11410 Views

Last post by nordberg
12 Jun 2015, 06:27
Cooling/Radiator Problem

Last post by Lewis.. « 11 Jun 2015, 20:41
Replies: 5
by Lewis.. » 11 Jun 2015, 12:20

Hi there,

I've recently drained and flushed my coolant after seeing the state of the stuff in there before. Its all been re filled and bled...

5 Replies

2044 Views

Last post by Lewis..
11 Jun 2015, 20:41
Pressure Cap Question

Last post by Ant-t « 11 Jun 2015, 15:49
Replies: 2
by Ant-t » 11 Jun 2015, 12:57

I've recently completed a coolant change, I've checked the coolant level in the header tank for the last two mornings and it needs topping up but the...

2 Replies

830 Views

Last post by Ant-t
11 Jun 2015, 15:49
Engine tray advantages/disadvantages for it ?

Last post by Dubwana « 11 Jun 2015, 14:19
Replies: 5
by sternal » 10 Jun 2015, 22:35

Have removed the engine tray as want to clean it up, glad I removed it, it had 30 years of gunk and who knows what on it.

I'm going to put it back...

5 Replies

1542 Views

Last post by Dubwana
11 Jun 2015, 14:19
Quality of rear wheel bearing kits

Last post by NicBeeee « 11 Jun 2015, 09:57
Replies: 4
by NicBeeee » 10 Jun 2015, 12:31

Hi,

Just wondering if anyone could give me there thoughts on the quality of rear wheel bearing kits, I have an MOT tommorrow at 8:30 and after...

4 Replies

1354 Views

Last post by NicBeeee
11 Jun 2015, 09:57
Correct Distributor for 1981 CU engine?

Last post by chrisdc « 11 Jun 2015, 08:53
Replies: 6
by chrisdc » 31 May 2015, 22:22

Hi,

I'm rebuilding my engine and have discovered a few anomalies with the carburetor and distributor setup. The carbs will be another post, but the...

6 Replies

2259 Views

Last post by chrisdc
11 Jun 2015, 08:53
Breather tank ventilation valve

Last post by smurfbus « 10 Jun 2015, 20:48
Replies: 2
by smurfbus » 08 Jun 2015, 20:24

Like it seems quite a few people I have managed to snap a breather tank ventilation valve while removing the breather tank. Doing a complete overhaul...

2 Replies

1037 Views

Last post by smurfbus
10 Jun 2015, 20:48
Sudden white smoke whilst driving

Last post by Emma&Al « 10 Jun 2015, 20:34
Replies: 11
by Emma&Al » 07 Jun 2015, 10:34

So the van passed its MOT 3 days back and I was SO pleased! :)
I took the van for a long drive yesterday and about an hour in, suddenly, I could see...

11 Replies

5254 Views

Last post by Emma&Al
10 Jun 2015, 20:34
Sliding door locking...the pain continues...

Last post by mark « 10 Jun 2015, 17:58
Replies: 2
by lian » 10 Jun 2015, 14:12

Have posted this to the facetube groups too so please bear with....

Is there anyone based close to Norwich who has intimate knowledge of hos the...

2 Replies

1390 Views

Last post by mark
10 Jun 2015, 17:58
Engine refused to run on petrol

Last post by itchyfeet « 10 Jun 2015, 14:58
Replies: 9
by pandp38 » 11 May 2015, 19:22

Had a scarey moment . I intentionally ran out of lpg whilst measuring the range of tankfull of gas.
Sod's law the tank emptied just as I pulled onto...

9 Replies

2532 Views

Last post by itchyfeet
10 Jun 2015, 14:58
IP Dial Gauge Purchasing Advice Please

Last post by Dubwana « 10 Jun 2015, 12:48

by Dubwana » 10 Jun 2015, 12:48

I'm driving a 1981 1.6D and need to set the IP properly. I've been doing it by ear since I bought the van, no-one here in Kenya has the gauge so I...

0 Replies

1708 Views

Last post by Dubwana
10 Jun 2015, 12:48
Total MV Engine Rebuild 2.0

Last post by matteochiochetta « 09 Jun 2015, 22:41
Replies: 8
by matteochiochetta » 11 May 2015, 15:29

Hi all,
first of all I want to say hello and thanks to everyone who runs and use this forum. Just can't live without!
I am a registered user from...

8 Replies

2843 Views

Last post by matteochiochetta
09 Jun 2015, 22:41
Nut and bolt size

Last post by Daisy « 09 Jun 2015, 20:28
Replies: 6
by Daisy » 03 Jun 2015, 20:19

Hi, can some body tell me the NUT and Bolt size for the bottom of the rear shock absorber strut and where I would be able to get them from please, as...

6 Replies

1580 Views

Last post by Daisy
09 Jun 2015, 20:28
Single weber carb problem

Last post by nedkelly113 « 09 Jun 2015, 19:31

by nedkelly113 » 09 Jun 2015, 19:31

Hi
I've just put a new head on one side of a 2.0 CU engine. It started first time. I had the air filter off while it was started. one chamber was...

0 Replies

1712 Views

Last post by nedkelly113
09 Jun 2015, 19:31
Changing a cylinder head

Last post by kevtherev « 09 Jun 2015, 16:50
Replies: 8
by windydubber » 27 May 2015, 06:41

Hi,
I'm contemplating that I may need to change a cylinder head for various reasons. My questions are, is it ok to just change one side? Also, What...

8 Replies

2506 Views

Last post by kevtherev
09 Jun 2015, 16:50
GSF exhaust quality

Last post by Mk2Tony « 09 Jun 2015, 11:53
Replies: 11
by Mk2Tony » 08 Jun 2015, 12:16

Hey guys,

Just wondering if anyone has had any experience with GSF exhausts quality wise? I was going to order the twin Empi until I read about them...

11 Replies

3729 Views

Last post by Mk2Tony
09 Jun 2015, 11:53
Diesel air filter fitting

Last post by matt brighton « 09 Jun 2015, 05:12
Replies: 3
by kit » 08 Jun 2015, 17:02

Does anyone please know (or have a diagram) of which way up the air filter goes in the CS air box, I just have a feeling I have fitted it upside down...

3 Replies

881 Views

Last post by matt brighton
09 Jun 2015, 05:12
Facet pump

Last post by what2do « 08 Jun 2015, 21:21
Replies: 4
by what2do » 08 Jun 2015, 10:20

This pump is fitted to a cross flow in a Westfield, so not vw what so ever. It's a friends who tinkers and worse of all hits the car with a scatter...

4 Replies

945 Views

Last post by what2do
08 Jun 2015, 21:21
Gearbox oil leak - selector shaft

Last post by fodtommo « 08 Jun 2015, 13:20
Replies: 7
by fodtommo » 04 Jun 2015, 10:09

Hi All

I recently had to remove the gearbox to do a clutch change along with release arm and associated components.

While the box was out I gave it...

7 Replies

4332 Views

Last post by fodtommo
08 Jun 2015, 13:20
Accelerator Cable Sequence

Last post by garrytheskate « 08 Jun 2015, 13:03

by garrytheskate » 08 Jun 2015, 13:03

'84 1.9 LT25 Camper Van
Is there a sequence for replacing the accelerator cable, any problems to watch out for.
Thanks

0 Replies

1750 Views

Last post by garrytheskate
08 Jun 2015, 13:03
slight misfire

Last post by Mk2Tony « 08 Jun 2015, 09:46
Replies: 3
by Mk2Tony » 01 Jun 2015, 07:15

Hey guys, took my van out for a run to pick the wife up yesterday and noticed a slight misfire, only seems to be at low revs, also get popping on...

3 Replies

1168 Views

Last post by Mk2Tony
08 Jun 2015, 09:46
Re Con Gearbox.

Last post by gtrbikeman « 08 Jun 2015, 07:10
Replies: 2
by gtrbikeman » 07 Jun 2015, 11:17

Hi,
Anyone know of Garage in Liverpool or near who can supply and fit us a gearbox.
Thank you...

2 Replies

1123 Views

Last post by gtrbikeman
08 Jun 2015, 07:10
Idle mixture enrichment unit - correct resistance

Last post by chrisdc « 08 Jun 2015, 06:40
Replies: 2
by chrisdc » 05 Jun 2015, 20:53

Hi,

My idle mixture enrichment unit on my solex PDSIT carbs is broken - was in kit form when I removed the four screws from the cover :!: Can...

2 Replies

1157 Views

Last post by chrisdc
08 Jun 2015, 06:40
Heater pod issue

Last post by windydubber « 07 Jun 2015, 21:28
Replies: 9
by windydubber » 07 Jun 2015, 14:53

Hi All,
I managed to get under the van properly for the first time today instead of having a cursory glance! My main reason was to see why the heater...

9 Replies

2792 Views

Last post by windydubber
07 Jun 2015, 21:28
Bentley manual engine verification

Last post by G Dub52 « 07 Jun 2015, 19:45
Replies: 4
by G Dub52 » 07 Jun 2015, 11:25

Hello all! In the Bentley manual there is a digifant and a digijet water cooled petrol layout. For my 1.9 DG which is the correct engine spec so I...

4 Replies

1179 Views

Last post by G Dub52
07 Jun 2015, 19:45
Gearbox type

Last post by vanhatter « 07 Jun 2015, 18:10
Replies: 2
by vanhatter » 07 Jun 2015, 14:54

Hi all,

Think this has probably already been covered before but can't find it. Anyway, thinking I ought to change the gearbox oil and the Haynes...

2 Replies

1191 Views

Last post by vanhatter
07 Jun 2015, 18:10
engine cutting out and struggles up hills

Last post by CovKid « 07 Jun 2015, 16:49
Replies: 4
by stokeseys1974 » 07 Jun 2015, 08:34

Hi. I have a 1.9dj lpg conversion pop top westfalia. Problem is it k cuts out when changing down gear. When started from cold i have to keep revs up...

4 Replies

1339 Views

Last post by CovKid
07 Jun 2015, 16:49
Air con rad

Last post by KINGPRAWN « 07 Jun 2015, 14:48
Replies: 3
by KINGPRAWN » 29 May 2015, 09:36

I need to replace my air con rad on my 2.1 Westy syncro .... Where do I start ???? :?

3 Replies

1406 Views

Last post by KINGPRAWN
07 Jun 2015, 14:48
Identifying my 1.9d engine

Last post by ELVIS « 14 Jun 2015, 12:56
Replies: 8
by stevie43_uk » 07 Jun 2015, 11:40

Hi All,

I'm trying to identify what type of 1.9d engine I have so I can order parts for it.
The block has been line bored and new shells, rings etc...

8 Replies

2984 Views

Last post by ELVIS
14 Jun 2015, 12:56
oil filler neck

Last post by CJH « 07 Jun 2015, 08:40
Replies: 14
by Jonogood » 23 May 2015, 07:30

Hi,

The plastic oil filler neck on my '89 1.9 petrol has split and I have been trying to source a replacement without success. Can anyone suggest...

14 Replies

5898 Views

Last post by CJH
07 Jun 2015, 08:40
leaky valve seal

Last post by dave friday « 07 Jun 2015, 07:23
Replies: 7
by dave friday » 05 Jun 2015, 00:15

Hi all,so how perfect does the seal have to be? when I pour petrol into the ports I get varying amounts of seepage...
Ta.

7 Replies

1528 Views

Last post by dave friday
07 Jun 2015, 07:23
WBX running weak

Last post by kevtherev « 07 Jun 2015, 07:07
Replies: 1
by Budgie7 » 06 Jun 2015, 23:25

Hi , my van a 2.1 dj auto and whilst checking the emissions found it to be running very week. Any ideas as to why or what causes this .It was reading...

1 Replies

606 Views

Last post by kevtherev
07 Jun 2015, 07:07
Continuing exhaust problem

Last post by Oldiebut goodie « 06 Jun 2015, 20:19
Replies: 7
by vinylbumra » 03 Jun 2015, 20:33

Hi there everyone apologies in advance for the essay! I am a newbie to joining the forum but have had my 1990 ex deutche telecom 1.7d t25 for 4 years...

7 Replies

2107 Views

Last post by Oldiebut goodie
06 Jun 2015, 20:19
Edited - just 1 stupid question now, rear wiper turn on?

Last post by chewbacca « 06 Jun 2015, 15:14
Replies: 16
by chewbacca » 05 Jun 2015, 20:41
1

2
Help please guys.

Stupid question.... How do I turn the rear wiper on. I've never used it but want to test it now. I thought you pushed the wiper...
16 Replies

2886 Views

Last post by chewbacca
06 Jun 2015, 15:14

New Topic

7523 topics

Page 124 of 151
- Jump to page:
Previous
1
…
122
123
124
125
126
…
151
Next

Return to Board Index

Forum permissions

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum