Search results
From VW T25(T3)-Tech
Jump to navigationJump to search
Page title matches
- '''Technical Starter Motor Information''', an insight into starter earthing and T25 specific issues plus their causes. The early manual petrol wbx starter is smaller and lower power than the late one but they are interchangeable ( ...7 KB (1,281 words) - 20:37, 23 November 2015
- Any ideas on the best way of removing the starter motor bush on a 2lt air cooled? Have tried using an expanding bolt. ...d to fit new bush, lightly bite the extractor into the bush to hold it the starter motor hole as square as you can, and push in (small mirror and light helps ...2 KB (450 words) - 22:39, 29 November 2009
- ...ngine but the engine bay does not so this thich cable may pull against the starter connection if it is too tight leading to a breakage of the solenoid. So it and butt connector for the starter end CTT10 you could probably crimp this in a vice or ask to get them to do ...2 KB (440 words) - 18:41, 18 April 2012
- '''Anon: ''' Starter Motor & Bush replacement - 2.0 litre Air-cooled ...s an oilite(porous bronze) bush and fits in the bellhousing supporting the starter's pinion extension. ...10 KB (1,912 words) - 20:22, 30 May 2013
Page text matches
- Cheap working light for inaccessible areas (starter motor bell housing when used with a mirror, esp syncro!) ...139 bytes (20 words) - 10:30, 24 August 2008
- ...ed owners, remove the earth strap from the mount and put one direct to the starter motor where it belongs and if you get chance take the mount off, remove the ...t someone leaning into the engine bay to attach the connection and put the starter motor second bolt on ...1 KB (221 words) - 06:48, 2 April 2012
- ...ngine but the engine bay does not so this thich cable may pull against the starter connection if it is too tight leading to a breakage of the solenoid. So it and butt connector for the starter end CTT10 you could probably crimp this in a vice or ask to get them to do ...2 KB (440 words) - 18:41, 18 April 2012
- ...starter motor main connection it goes from the battery to the Alt VIA the starter motor and it is specifically positioned by VW to catch a fresh mist of love ...l engine faults/repairs/maintenance reluctant starting|Reluctant starting (starter motor)]] ...2 KB (455 words) - 11:58, 25 November 2007
- Pop under the driverside rear wheel arch and check the signal wire to the starter motor is connected to the spade connector on the solenoid. ...not turning over, See 1, starter motor seized or electrical connection to starter motor loose. ...10 KB (1,761 words) - 11:13, 25 September 2007
- ...achined off the shoulder to the rear of the starter motor ring gear so the starter nose/end suport bearing did'nt fowl the flywheel and there where two tiny l 3 photo of machining on 02A flywheel to clear starter motor nose support bearing casting ...3 KB (553 words) - 00:09, 2 January 2007
- Any ideas on the best way of removing the starter motor bush on a 2lt air cooled? Have tried using an expanding bolt. ...d to fit new bush, lightly bite the extractor into the bush to hold it the starter motor hole as square as you can, and push in (small mirror and light helps ...2 KB (450 words) - 22:39, 29 November 2009
- ...es wires to take current to the various devices on the vehicle like lights starter motor etc then uses the bodywork metal for the return circuit for the batte ...olenoid to starter breaking down, and eventuall fracturing completely. New starter motor fitted. ...3 KB (547 words) - 10:07, 9 May 2011
- '''Technical Starter Motor Information''', an insight into starter earthing and T25 specific issues plus their causes. The early manual petrol wbx starter is smaller and lower power than the late one but they are interchangeable ( ...7 KB (1,281 words) - 20:37, 23 November 2015
- ...fires is above the starter motor... the wiring from the battery +ve to the starter motor +ve can sometimes flex/wear and degrade to the point that engine rock ...3 KB (487 words) - 14:21, 27 October 2008
- ...eard from the rear? > No:''' Check ignition barrel plug and connections to starter motor are clean and tight. It's common for the signal wire to fall off the ...915 bytes (158 words) - 19:51, 11 October 2008
- .... On a daily use cycle, the standard so called leisure battery (which is a starter battery) will last you as little as 6 – 8 months whereas traction would las ...s, because they are all basically the same battery. A Gel and conventional starter battery go down the same production line until one has a gel substance put ...9 KB (1,688 words) - 17:15, 9 September 2008
- Disconnect the alternator, fuel line from the tank, at the pump. The starter motor cables. Also the servo vacuum line on the LH side of the engine bay. ...1 KB (198 words) - 21:47, 5 November 2006
- Flange with hole for starter motor bolt can break (see pics) ...k end of strap; make a 2.5 ft loop at that end; put loop through gap under starter motor, drop down o/s of bellhousing'' ...2 KB (312 words) - 10:57, 14 July 2010
- 15 - Switched live from igniton switch (also live when starter is running) ...hen starting - those circuits don't apear to stop working when you run the starter because of voltage drop, they stop working because they are actully turned ...2 KB (382 words) - 09:06, 11 March 2011
- '''Anon: ''' Starter Motor & Bush replacement - 2.0 litre Air-cooled ...s an oilite(porous bronze) bush and fits in the bellhousing supporting the starter's pinion extension. ...10 KB (1,912 words) - 20:22, 30 May 2013
- ...rter motor. (Note: the main positive feed from the starting battery to the starter motor isn't shown on this diagram) The terminal that was going to 30 (starter battery) now goes to C1 (this 6.3mm female needs changing for a larger 9.5m ...4 KB (667 words) - 21:00, 19 October 2014
- ...main heavy-gauge cables that go from alternator to starter, and battery to starter, can be subject to deterioration. The thickest cable by far is the one between the battery and starter and if you drive a T25 with your main battery behind the drivers seat, you' ...9 KB (1,690 words) - 08:25, 15 October 2015
- ...re succesfully used on pipes and sleeves that are stuck e.g. bushes, as in starter motor bushes on T25s ...1 KB (194 words) - 22:53, 29 November 2009
- ...d (stuck/failed) /ignition switch/wiring /starter pinion support bush /bad starter (field/armature etc)<br> ...4 KB (679 words) - 06:59, 17 June 2014
