Mechanical

Moderators: User administrators, Moderators

New Topic

15635 topics

Page 173 of 313
- Jump to page:
Previous
1
…
171
172
173
174
175
…
313
Next

Topics

Replies

Views

Last post

i' ve never had a diesel before!

Last post by tomsneade « 08 May 2010, 14:58
Replies: 9
by tomsneade » 06 May 2010, 12:41

Hi, is it usual to have to use the choke every time on a diesel engine and for it to struggle for 10 secs or so before firing up? I am used to my...

9 Replies

1286 Views

Last post by tomsneade
08 May 2010, 14:58
Diesel Engine

Last post by toomanytoys « 08 May 2010, 13:04
Replies: 5
by Tug » 08 May 2010, 09:34

Hi,

I need a little advice with regards to which engine / parts I need to install a Diesel engine in to my Camper.
Im no novice when it comes to...

5 Replies

647 Views

Last post by toomanytoys
08 May 2010, 13:04
Fierce Clutch

Last post by pionte « 07 May 2010, 23:06
Replies: 11
by CovKid » 02 May 2010, 09:14

Any idea how long my new clutch will take to bed in? The old one was getting close to the rivets so fitted a new clutch when I removed the transaxle...

11 Replies

1265 Views

Last post by pionte
07 May 2010, 23:06
judder, judder costing me £££'s

Last post by toomanytoys « 07 May 2010, 21:36
Replies: 18
by mrtanz » 07 May 2010, 18:07
1

2
Hi all,

Poorly t25 camper 1980 1584cc air cooled CT enginge code.

Serious Judder from the back when driving.

Checked the engine mounts, Had a new...
18 Replies

2121 Views

Last post by toomanytoys
07 May 2010, 21:36
Aircooled/watercooled tappets

Last post by faggie « 07 May 2010, 21:15
Replies: 4
by Ian Hulley » 07 May 2010, 08:32

Are these one and the same ?

Ian.

4 Replies

825 Views

Last post by faggie
07 May 2010, 21:15
Crankshaft Seal - Flywheel Bolts.....

Last post by T25Convert « 07 May 2010, 19:57
Replies: 17
by T25Convert » 06 May 2010, 21:39
1

2
Hi All,

I'm currently dropping engine oil all over the place, so its time to do the crank seal behind the flywheel.

I've read the WIKI, the Haynes...
17 Replies

3315 Views

Last post by T25Convert
07 May 2010, 19:57
Valve settings

Last post by Steve Goddard « 07 May 2010, 19:24
Replies: 2
by Steve Goddard » 06 May 2010, 21:25

Hi
Could anyone run me through the basics of valve settings for a water cooled 1.9?
The Haynes manual is very vague .
What I need to know is the...

2 Replies

548 Views

Last post by Steve Goddard
07 May 2010, 19:24
boost pin upgrade

Last post by ringo « 07 May 2010, 14:19
Replies: 5
by paulweld » 07 May 2010, 07:44

Hi been trying to find info on the boost pin upgrade for my aaz conversion but cant find any so far ( how to change it etc ) ! any pointers /help...

5 Replies

1462 Views

Last post by ringo
07 May 2010, 14:19
air cooled oil leak through the petrol pump

Last post by bigherb « 07 May 2010, 10:30
Replies: 2
by scootersjamie » 06 May 2010, 19:00

i have a 2.0 litre air cooled transporter,fitted with elecfric fuel pump,it still has the origanel pump fitted which has just started dripping...

2 Replies

540 Views

Last post by bigherb
07 May 2010, 10:30
Cold start ok - warm/hot start not so ok (2.1DJ/LPG)

Last post by smcd999 « 06 May 2010, 18:10
Replies: 5
by Yozza » 03 May 2010, 06:24

Ay up,
I've had a few problems lately so I apologise for yet another thread! Recently she has been playing up, when it's a cold start she'll fire up...

5 Replies

1079 Views

Last post by smcd999
06 May 2010, 18:10
life span of a 1.6td

Last post by AndyRach « 06 May 2010, 17:54
Replies: 13
by si&helen cali89 » 03 May 2010, 17:46

i have a 1989 westy cali 1.6td its just completed 130000 miles i no there are many factors to alife of an engine but just wondered how many more...

13 Replies

1821 Views

Last post by AndyRach
06 May 2010, 17:54
Turbo rebuild - any advice?

Last post by Hoss « 06 May 2010, 17:27
Replies: 3
by Hoss » 03 May 2010, 21:30

Hello all,
I've found a rebuild kit online and am thinking of saving myself a small fortune and doing it myself. I don't think my turbo problem is...

3 Replies

597 Views

Last post by Hoss
06 May 2010, 17:27
1.9 to 2.1

Last post by ricicles « 06 May 2010, 16:35
Replies: 57
by texasuk » 15 Mar 2010, 20:08
1

2

3

4
I've searched here, the Wiki and the tech archive and can't find a direct answer so I'm taking the risk and asking it out loud here.

Can you just...
57 Replies

6317 Views

Last post by ricicles
06 May 2010, 16:35
Fuel Drain Back

Last post by jamesc76 « 06 May 2010, 15:56
Replies: 5
by Titus A Duxass » 06 May 2010, 11:34

JX 1,6 TD.
For some reason the fuel is draining back into the tank when I park up over a couple of days.

At the Syncro 25 bash we were parked for 4...

5 Replies

719 Views

Last post by jamesc76
06 May 2010, 15:56
leaky injector pipe?

Last post by R0B « 06 May 2010, 13:01
Replies: 2
by lhd » 05 May 2010, 22:00

Is there any thing that can be done or is it a replacement? :?
Cheers Rob.

2 Replies

517 Views

Last post by R0B
06 May 2010, 13:01
diesel engine and glow plug indicator light

Last post by gaz f « 06 May 2010, 12:15
Replies: 2
by tomsneade » 06 May 2010, 12:03

Hi. Could anybody advise me on how long I should wait before turning the ignition switch fully on if my glow plug indicator light is not working and...

2 Replies

603 Views

Last post by gaz f
06 May 2010, 12:15
1.9dg temp gauge

Last post by little.legs « 06 May 2010, 12:05
Replies: 12
by little.legs » 24 Apr 2010, 13:07

Hi, having done search I'm getting really confused with my temp gauge. Most people seem to say theirs reads about halfway. In the 2 years I've had...

12 Replies

2190 Views

Last post by little.legs
06 May 2010, 12:05
accidentally drilled a hole

Last post by jimpainter « 06 May 2010, 12:03
Replies: 9
by treacle » 04 May 2010, 20:56

i accidentally drilled a hole in the top of the N/Side Fuel expansion tank
will i have to replace it or can i just plug it i did it when i was...

9 Replies

1337 Views

Last post by jimpainter
06 May 2010, 12:03
I think its terminal

Last post by neil3965 « 06 May 2010, 10:26
Replies: 41
by albertramsbottom » 02 May 2010, 12:54
1

2

3
Over heated again today after 40 mins idling. timed it 5degs ATDC. Still the same, the oil light starts to flicker and the engine is very hot. In...
41 Replies

5222 Views

Last post by neil3965
06 May 2010, 10:26
1.6td timing marks for crank pulley?

Last post by vwwidow « 06 May 2010, 07:46
Replies: 3
by vwwidow » 05 May 2010, 17:55

please forgive me if the answer is here on the forum somewhere but i have searched and couldnt find it.

im trying to find timing marks for the crank...

3 Replies

845 Views

Last post by vwwidow
06 May 2010, 07:46
Dizzy wiring plug

Last post by orangebooboobearcrew « 05 May 2010, 22:23
Replies: 1
by orangebooboobearcrew » 03 May 2010, 16:41

Hello,

The wiring plug on our dizzy snapped off when I was trying to refit last week - d'oh :shock:

I ordered a replacement Hall sender from JK...

1 Replies

432 Views

Last post by orangebooboobearcrew
05 May 2010, 22:23
Hydraulic or Mechanical lifters

Last post by albertramsbottom « 05 May 2010, 21:09
Replies: 1
by albertramsbottom » 05 May 2010, 20:49

Emmmm

I adjusted me valve clearances to 0.006 today and then subsequently read in my Aircooled rebuild engine book that the use of a feeler guageis...

1 Replies

438 Views

Last post by albertramsbottom
05 May 2010, 21:09
handbrake trouble

Last post by fairwynds « 05 May 2010, 12:33
Replies: 8
by purplecrocs » 04 May 2010, 11:34

Hi.

I'm having trouble with my handbrake, basically it won't hold the van on a slope unless I really pull it up hard - i mean with quite a lot of...

8 Replies

1031 Views

Last post by fairwynds
05 May 2010, 12:33
gear selection front

Last post by Plasticman « 04 May 2010, 23:21
Replies: 21
by Epiphone » 23 Feb 2010, 17:05
1

2
Hi all, tralled through a few threads on hear about gear selectin. Ive had trouble with mine since the day I bought it.

get a clicking noise when...
21 Replies

3628 Views

Last post by Plasticman
04 May 2010, 23:21
Vacuum advance

Last post by toomanytoys « 04 May 2010, 20:40
Replies: 2
by djhammy » 04 May 2010, 19:26

HI guys just had the vacuum advance unit replaced on my distributor. My Mechanic said the original one had broken as it couldn't move the distributor...

2 Replies

583 Views

Last post by toomanytoys
04 May 2010, 20:40
Fuel hose

Last post by Red Westie « 04 May 2010, 20:38
Replies: 1
by kentishvanman » 04 May 2010, 19:42

Hi,
Has anyone changed/replaced the hoses on their breather tank system.
WIKI says it's do-able with wheel off, any comments?
Difficult to see from...

1 Replies

414 Views

Last post by Red Westie
04 May 2010, 20:38
Yet another speedo question - legal aspect to this one

Last post by Red Westie « 04 May 2010, 20:37
Replies: 4
by silverbullet » 04 May 2010, 16:13

I had to change the speedo in the 2.6 SA since it was reading a good 10% slow - not good. The one fitted said 805 on the face (but strange numerals,...

4 Replies

715 Views

Last post by Red Westie
04 May 2010, 20:37
brake pads backing coming off............

Last post by VWCamperfan « 04 May 2010, 18:13
Replies: 4
by gti mad man » 03 May 2010, 17:00

my front brakes squeeked so toiok them off for a clean re copper grease but noticed on the rear of the pads the rubber type plastic coating had worn...

4 Replies

627 Views

Last post by VWCamperfan
04 May 2010, 18:13
collapsed tappet?

Last post by VWCamperfan « 04 May 2010, 17:58
Replies: 1
by Rozzo » 04 May 2010, 17:32

hi
2.0 CU engine
can anyone tell me wether its normal to be able to push the pushrod end of one of my rockers in half an inch by finger pressure? i...

1 Replies

455 Views

Last post by VWCamperfan
04 May 2010, 17:58
Starter doesnt start because the spade connector gets fusty

Last post by ringo « 04 May 2010, 17:06
Replies: 9
by ringo » 29 Apr 2010, 20:30

Really annoys me this - and it seems to happen once a year if not more.

Got into the van today and it wouldnt start - turned the key and nada.

I...

9 Replies

993 Views

Last post by ringo
04 May 2010, 17:06
Speedo dots

Last post by a1winchester « 04 May 2010, 15:55
Replies: 10
by baldiebird » 03 May 2010, 17:21

Hi,
Just returned from my forth camping trip since getting my van in December (very nice). However I was having a few problems getting up hills, much...

10 Replies

1663 Views

Last post by a1winchester
04 May 2010, 15:55
Loud squeal when full lock on

Last post by albertramsbottom « 04 May 2010, 15:48
Replies: 3
by catflaps » 04 May 2010, 11:02

Hello,
I have developed a loud squeal that comes from the van when I have the steering turned full lock in either direction. Only noticable when...

3 Replies

571 Views

Last post by albertramsbottom
04 May 2010, 15:48
Speedo hub cover

Last post by CovKid « 04 May 2010, 14:59
Replies: 2
by westyguesty » 04 May 2010, 14:14

Any idea where I can get one from, local VW dealer said they can't get one. It's the cover that the speedo cable goes through, not square anymore, so...

2 Replies

662 Views

Last post by CovKid
04 May 2010, 14:59
1.9 dg firing on three cylinders

Last post by jake1953 « 04 May 2010, 12:02
Replies: 2
by jake1953 » 04 May 2010, 10:33

Van's been going great until yesterday when it starts but only fires on three cylinders.
The van's been sitting for a week at my workplace so not...

2 Replies

504 Views

Last post by jake1953
04 May 2010, 12:02
Engine bay seal

Last post by CovKid « 04 May 2010, 09:10
Replies: 1
by albertramsbottom » 04 May 2010, 09:08

Whilst my engine bay seal is good and seals all the way round there is a gap of about 9 right at the rear of the engine bay, right in the middle. So...

1 Replies

454 Views

Last post by CovKid
04 May 2010, 09:10
Brake Fluid Change....problems

Last post by noggintom « 04 May 2010, 07:07
Replies: 9
by noggintom » 30 Apr 2010, 18:41

Hi all,

I've been having an eventful week VW-wise this week. A new alternator (from Bosch so now poor) and some fun trying to drain the brake fluid....

9 Replies

1013 Views

Last post by noggintom
04 May 2010, 07:07
Van cutting out at junctions

Last post by CovKid « 03 May 2010, 22:51
Replies: 15
by golf2tim » 02 May 2010, 17:28
1

2
Hi, I have an 1.6 air cooled van and it has a problem of when depressing the clutch and slowing down it cuts out, but if you restart it, it will idle...
15 Replies

2943 Views

Last post by CovKid
03 May 2010, 22:51
water pipe split..

Last post by ryoc « 03 May 2010, 12:34
Replies: 10
by ryoc » 01 May 2010, 16:32

Driving home today in my 1990 Caravelle 2.1 petrol, the small right angled water pipe just above the oil filter split.
A bit difficult to get to the...

10 Replies

1487 Views

Last post by ryoc
03 May 2010, 12:34
Exhaust bracket snapped??

Last post by Hacksawbob « 02 May 2010, 19:48
Replies: 6
by Matt The Hat » 15 Apr 2009, 19:01

Alright,

This bracket from my exhaust has just snapped today, been rattling a little bit for a while. Is this the correct set up? or should there be...

6 Replies

821 Views

Last post by Hacksawbob
02 May 2010, 19:48
sump plug wont tighten small leak

Last post by happy camper « 02 May 2010, 15:12
Replies: 4
by macaw » 01 May 2010, 17:22

Hi done oil change myself and now the sump plug leaking slightly and wont tighten
:idea

4 Replies

1186 Views

Last post by happy camper
02 May 2010, 15:12
Oh bugger.... looks like I'll be needing a new engine then?

Last post by famous phil « 02 May 2010, 13:46
Replies: 22
by mikeymancs » 30 Apr 2010, 12:31
1

2
Hi!

Hope you guys can offer some advice here.

Have posted a few times on here about my 1988 1.6 Turbo Diesel JX engine. It has 115k and running...
22 Replies

3051 Views

Last post by famous phil
02 May 2010, 13:46
Flushing Rust out of Block and Hoses

Last post by wagenbod « 02 May 2010, 09:54
Replies: 2
by wagenbod » 01 May 2010, 15:24

I've just removed rotted radiator and rotted front to back metal water pipes. I think they contained tomato soup! I'd like to get as much crap out of...

2 Replies

640 Views

Last post by wagenbod
02 May 2010, 09:54
Starting Problem

Last post by Robinho08 « 02 May 2010, 09:22
Replies: 2
by Robinho08 » 30 Apr 2010, 22:26

Hi there,

Wonder if anyone could lend any advice please?

My T25 1.9(WC) wont start, it turns over but just wont start, had a look at the dizzy,...

2 Replies

474 Views

Last post by Robinho08
02 May 2010, 09:22
Fan belt size for a 1.9d 1Y

Last post by armyphil « 02 May 2010, 07:54
Replies: 2
by armyphil » 30 Apr 2010, 19:20

Any body know mine hasn't got any markings on after a quick look the other day it looks quite perished.

Cheers all

2 Replies

718 Views

Last post by armyphil
02 May 2010, 07:54
Basic Oil Change Question

Last post by T'Onion « 02 May 2010, 07:15
Replies: 8
by si macc » 30 Apr 2010, 18:02

Hi everyone,

I am going to have a go at doing my first oil change (ever!) and wanted to check to see if the guide on the wiki for petrol engines is...

8 Replies

1134 Views

Last post by T'Onion
02 May 2010, 07:15
Buzzer of Doom is back...feck

Last post by 4gearwonder « 01 May 2010, 21:01
Replies: 15
by pocolow » 12 Apr 2010, 21:32
1

2
After many months of quiet motoring the bliddy BOD is back. Did an oil and filter change two weeks ago(quantum 15/40) and genuine VW filter all fine...
15 Replies

3234 Views

Last post by 4gearwonder
01 May 2010, 21:01
petrol tank

Last post by toomanytoys « 01 May 2010, 20:05
Replies: 2
by jabba » 01 May 2010, 19:49

hi could anyone tell me the best way to remove and wash out petrol tank please. think its got bits in it ,keeps blocking carb.

2 Replies

574 Views

Last post by toomanytoys
01 May 2010, 20:05
Timing Confusion

Last post by toomanytoys « 01 May 2010, 18:33
Replies: 14
by albertramsbottom » 20 Apr 2010, 14:30

Hi

I am a bit miffed as to what way the dizzy on my 2ltr CU engine should be turned to advance and retard my timming.

I have just read on type2.com...

14 Replies

1184 Views

Last post by toomanytoys
01 May 2010, 18:33
Water cooled - Manifold air filter pickups

Last post by ali_rob_marcus « 01 May 2010, 15:48
Replies: 3
by ali_rob_marcus » 29 Apr 2010, 11:46

I have some rather tatty bit of ali tubeing hanging from my exhaust pipe. Can anyone tell me where they connect onto. I beleive they both connect to...

3 Replies

538 Views

Last post by ali_rob_marcus
01 May 2010, 15:48
Oil at bottom of shock

Last post by el sketcho « 01 May 2010, 10:17
Replies: 7
by el sketcho » 24 Apr 2010, 15:12

I've got oil coming from around the bottom of the O/S front shock, they are only about a year old Avos that I brought from brickwerks. Does anyone...

7 Replies

1005 Views

Last post by el sketcho
01 May 2010, 10:17

New Topic

15635 topics

Page 173 of 313
- Jump to page:
Previous
1
…
171
172
173
174
175
…
313
Next

Return to Board Index

Forum permissions

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum