Mechanical

Moderators: User administrators, Moderators

7574 topics

Page 123 of 152
- Jump to page:
Previous
1
…
121
122
123
124
125
…
152
Next

Most liked posts	Author	Posted	Liked	Forum
Header Tank level	shrig1969	Yesterday, 01:38	Once this week	Mechanical
Forward where reverse should be.	Quzzy	01 Sep 2025, 10:32	Once this week	Mechanical

Topics

Replies

Views

Last post

Throttle valve stuck in fuel pump?

Last post by dave friday « 03 Jul 2015, 10:12
Replies: 1
by Kelvin16 » 02 Jul 2015, 22:18

Help required please! I finally got my van started after it lying idle for over 4 years. It's a 1.9 diesel. The main problem was loads of air in the...

1 Replies

566 Views

Last post by dave friday
03 Jul 2015, 10:12
Turbo pressure pipe insulation

Last post by dave friday « 03 Jul 2015, 07:09

by dave friday » 03 Jul 2015, 07:09

Morning All,as above what are you lot using for insulation on the pipe that goes from the turbo to the inlet manifold?
I can only buy very large...

0 Replies

1209 Views

Last post by dave friday
03 Jul 2015, 07:09
Won't start after running out of fuel!

Last post by dsmith1974 « 03 Jul 2015, 05:42
Replies: 10
by kevcorks » 27 Jun 2015, 13:20

Hi all

After a bit of advice. I ran out if petrol thus morning and after filling it with around ten litres couldn't get her started.

Engine...

10 Replies

2818 Views

Last post by dsmith1974
03 Jul 2015, 05:42
Unknown item in engine bay

Last post by RogerT « 02 Jul 2015, 21:18
Replies: 17
by Andyvandy » 02 Jul 2015, 15:13
1

2
Hi,

Please could someone enlighten me as to what this part is and its function.
Haynes doesn't do diesel models so not covered in the manual.

I...
17 Replies

6059 Views

Last post by RogerT
02 Jul 2015, 21:18
Clutch flexy fitting

Last post by RogerT « 02 Jul 2015, 20:49
Replies: 6
by RogerT » 02 Jul 2015, 12:26

I would like to fit a flex hose for my clutch, as at present I just have a pipe going straight to the slave cylinder. The movement broke the clutch...

6 Replies

1952 Views

Last post by RogerT
02 Jul 2015, 20:49
How to remove hub dust caps?!?!

Last post by Lucky82 « 02 Jul 2015, 20:25
Replies: 4
by Lucky82 » 02 Jul 2015, 18:54

Having a frustrating time trying to remove the dust caps from the wheel hub. Have been tapping and prizing with a screwdriver for the past few hours...

4 Replies

1321 Views

Last post by Lucky82
02 Jul 2015, 20:25
wbx oil pump o ring

Last post by itchyfeet « 02 Jul 2015, 20:07
Replies: 5
by itchyfeet » 01 Jul 2015, 20:30

So there is a groove that looks almost perfect for an o ring
looks to me like 1mm x 65mm ID viton oring would fit right in with about 0.2mm...

5 Replies

1241 Views

Last post by itchyfeet
02 Jul 2015, 20:07
Advice needed.

Last post by colinthefox « 02 Jul 2015, 18:21
Replies: 1
by andyf73 » 01 Jul 2015, 21:01

My fuel pump on my 1.6d has sprung a leak. I've got a reconditioned one, how easy/hard is it to change it myself.

1 Replies

587 Views

Last post by colinthefox
02 Jul 2015, 18:21
Engine upgrade maybe !

Last post by anaconda « 03 Jul 2015, 22:54
Replies: 4
by ssdt » 02 Jul 2015, 16:54

Have a doka with CSS diesel and 4speed box according to log book and gear stick should be Jx and 5 speed 5 on knob taped over have a chance of 1y...

4 Replies

2112 Views

Last post by anaconda
03 Jul 2015, 22:54
Solex 34 Pict 4 leaking fuel from throttle flap hinge

Last post by Wobba « 02 Jul 2015, 16:39
Replies: 5
by ed_the_robot » 15 Sep 2013, 15:51

Hey everyone.

I've just noticed this happening after getting a thread repaired on the base of the carb...

There is a fuel leak from this pivot...

5 Replies

3340 Views

Last post by Wobba
02 Jul 2015, 16:39
Suspension pop/knock

Last post by boiliebob « 02 Jul 2015, 08:35
Replies: 3
by boiliebob » 01 Jul 2015, 16:06

Good day Gents,
I'm back for more of your expert advice & help please. The front right suspension has, what i can only describe as, a pop/knock as it...

3 Replies

1156 Views

Last post by boiliebob
02 Jul 2015, 08:35
Warm Fast Idle

Last post by CK Joiner « 01 Jul 2015, 20:54
Replies: 4
by CK Joiner » 01 Jul 2015, 18:50

Ive been trying to sort out my fast idle on a 1.9DG Pierburg 2e carb to no success.
I have checked all hoses and replaced, done a full carb clean and...

4 Replies

1191 Views

Last post by CK Joiner
01 Jul 2015, 20:54
FNS Break Line to Hose Union

Last post by Oldiebut goodie « 01 Jul 2015, 20:52
Replies: 4
by bmouthboyo » 30 Jun 2015, 12:41

Hi guys,

My FNS Break Line is corroded and split so needs replacing. It's the small section that connects to the caliper hose, can anyone say if I...

4 Replies

1303 Views

Last post by Oldiebut goodie
01 Jul 2015, 20:52
Help wanted !

Last post by Richiee722 « 01 Jul 2015, 20:39
Replies: 4
by Richiee722 » 30 Jun 2015, 22:32

just like to say, great site.
I've been a watching member for a while but this is my first post.
I bought a Westy last year with 2.0cu engine and...

4 Replies

961 Views

Last post by Richiee722
01 Jul 2015, 20:39
Coolant Pressure Tanks

Last post by RobH « 01 Jul 2015, 17:58
Replies: 5
by RobH » 01 Jul 2015, 09:22

Are all coolant pressure tanks equal?

I have a weepy cap, it'seems been replaced but still not perfect, rim on the tank looks OK but wonder if I'd...

5 Replies

1382 Views

Last post by RobH
01 Jul 2015, 17:58
Loss of power/revs pulling away

Last post by kevtherev « 01 Jul 2015, 16:38
Replies: 21
by MidLifeCrisis » 21 Jun 2015, 16:56
1

2
Just driving back from weekend away.

Everything fine at first then got that sixth sense feeling that the acceleration didn't feel right - felt like...
21 Replies

5426 Views

Last post by kevtherev
01 Jul 2015, 16:38
vibrating gear stick

Last post by boiliebob « 01 Jul 2015, 16:14
Replies: 5
by rubyvan » 26 Jun 2015, 11:16

Hi
I have a problem with the gear stick vibrating, you cannot see it moving , but one can hear it and feel it vibrating.
Just to give you a little...

5 Replies

2195 Views

Last post by boiliebob
01 Jul 2015, 16:14
temp gauge needle issue, what should i be looking for?

Last post by spike blonde « 01 Jul 2015, 15:18
Replies: 12
by spike blonde » 30 Jun 2015, 13:33

first off thanks in advance any advice/ideas.
Ill be honest its been a while since ive been on here for advice as the last few jobs on the van have...

12 Replies

2896 Views

Last post by spike blonde
01 Jul 2015, 15:18
VWT25 mechanic near Peterborough/Stamford???

Last post by vw berty « 01 Jul 2015, 12:16
Replies: 3
by Gedward » 25 Jun 2015, 13:55

Hi All,
I'm going to be near Peterborough/Stamford next week and require a service for my T25 holdsworth.
Do you know or can any one recommend a...

3 Replies

938 Views

Last post by vw berty
01 Jul 2015, 12:16
rear swing arm question

Last post by silverbullet « 01 Jul 2015, 10:59
Replies: 9
by jameshamilton » 30 Jun 2015, 09:07

Morning

Just spotted a small rust hole in the offside rear swing arm. Does anyone know if this can be patched/welded, or am I looking at a new swing...

9 Replies

2774 Views

Last post by silverbullet
01 Jul 2015, 10:59
Do fuel pumps fail suddenly?

Last post by kevtherev « 30 Jun 2015, 21:43
Replies: 27
by ScienceBoy » 18 Jan 2015, 15:40
1

2
We were driving around in Harry quite happily a few weeks ago but since we've not been to start him. Diagnosis shows I can get fuel to the pump, but...
27 Replies

8445 Views

Last post by kevtherev
30 Jun 2015, 21:43
Tdi cone filters?

Last post by VWMartin « 02 Jul 2015, 12:49
Replies: 11
by VWMartin » 30 Jun 2015, 20:49

Hi guys

I'm running a 1z conversion in my T25 and I'm lacking space in my engine bay due to air box being on the wrong side of the bay.

Just...

11 Replies

4446 Views

Last post by VWMartin
02 Jul 2015, 12:49
Oil pressure switch woes!

Last post by silverbullet « 30 Jun 2015, 20:07
Replies: 17
by Cycleaddict » 25 Jun 2015, 18:31
1

2
Wondering if any has come across anything similar?
My van developed an annoying oil leak at the back of the engine-took it in to my local...
17 Replies

3842 Views

Last post by silverbullet
30 Jun 2015, 20:07
How to change speedo reading after replacing speedo ?

Last post by hulky « 30 Jun 2015, 13:35
Replies: 29
by hulky » 23 Jun 2015, 14:01
1

2
Hi does anyone know how I can change the speedo reading after I change my broken one ?
I want the new speedo to show the right mileage

Any advise...
29 Replies

10743 Views

Last post by hulky
30 Jun 2015, 13:35
How to change speedo cable 1990 westy

Last post by hulky « 30 Jun 2015, 12:26
Replies: 3
by hulky » 29 Jun 2015, 11:08

I have ordered a lhd speedo cable.
Can anyone run throught how to change please ?

thanks john

3 Replies

1148 Views

Last post by hulky
30 Jun 2015, 12:26
CP gearbox parts

Last post by kernewek « 30 Jun 2015, 08:22
Replies: 4
by kernewek » 29 Jun 2015, 20:13

Hi all, could anyone advise me where I might purchase a first gear set for a CP 2L gearbox? A mate here in France needs to sort his T2 box and the...

4 Replies

2269 Views

Last post by kernewek
30 Jun 2015, 08:22
Pushrods Tube Seals

Last post by Cob20 « 30 Jun 2015, 07:38

by Cob20 » 30 Jun 2015, 07:38

Morning.

I'm preparing to fix my leak from my pushrod area. (might as well get my hands dirty straight away). I'm assuming the seals are...

0 Replies

1348 Views

Last post by Cob20
30 Jun 2015, 07:38
JX Camshaft woes! Excessive end float

Last post by Timburrows « 29 Jun 2015, 21:01
Replies: 10
by Timeck » 26 Jun 2015, 08:18

SO having had grief getting the rocker cover off its finally off with a little persuasion however I've uncovered a problem that I hadn't anticipated....

10 Replies

2195 Views

Last post by Timburrows
29 Jun 2015, 21:01
Detent spring

Last post by Delbertini « 29 Jun 2015, 18:03
Replies: 4
by Delbertini » 26 Jun 2015, 22:57

Ok so I lost the detent ball and spring whilst rebuilding the gear linkage, well I presume I did or it was never there, not sure. Been following the...

4 Replies

1526 Views

Last post by Delbertini
29 Jun 2015, 18:03
battery light on, oil light flashing, won't turn

Last post by Oldiebut goodie « 29 Jun 2015, 14:17
Replies: 14
by Gavla80 » 25 Jun 2015, 21:41

Hi all - Just went out to start the engine as I've been really busy and haven't run it for a few weeks :oops: and was planning on taking the van out...

14 Replies

4700 Views

Last post by Oldiebut goodie
29 Jun 2015, 14:17
Over fuelling on starting

Last post by wizwilson « 29 Jun 2015, 12:35
Replies: 38
by wizwilson » 18 May 2015, 07:31
1

2

3
Hi, been doing some work on the van over weekend ( wiring to oil switches ) went to start it and it appearied to over fuel and die, check the plugs...
38 Replies

10496 Views

Last post by wizwilson
29 Jun 2015, 12:35
Ominous knocking sound

Last post by jameshamilton « 29 Jun 2015, 09:18
Replies: 2
by jameshamilton » 29 Jun 2015, 08:58

Hello,

New to this forum. New to owning a T25 for that matter. Anyhow, driving back from our maiden voyage yesterday, I noticed an ominous knocking...

2 Replies

1078 Views

Last post by jameshamilton
29 Jun 2015, 09:18
Overheating and oil pressure

Last post by kevtherev « 28 Jun 2015, 14:17
Replies: 6
by Chris197 » 27 Jun 2015, 20:50

Hey everyone,

Sorry to start my first post with a cry for help but here it goes......

Meet Horace. He's a 2.1 Caravelle on a 89 G reg. I've been...

6 Replies

1392 Views

Last post by kevtherev
28 Jun 2015, 14:17
Oil coolers

Last post by ScienceBoy « 28 Jun 2015, 12:51
Replies: 29
by ghost123uk » 19 Jan 2015, 11:01
1

2
I am very likely swapping from DG power to DJ power in the near future, but retaining my carb and manifold with BLOS LPG. I know most (all?) DJ...
29 Replies

9284 Views

Last post by ScienceBoy
28 Jun 2015, 12:51
cooling issue, or rather not cooling

Last post by ScienceBoy « 28 Jun 2015, 12:04
Replies: 18
by T25vanman » 09 Jun 2015, 20:00
1

2
Hi guys.
I'm trying to identify what the cause is on my 1.6d of water bubbling up and releasing from header tank.
My temp guage needle doesn't work...
18 Replies

7191 Views

Last post by ScienceBoy
28 Jun 2015, 12:04
Kickdown sticking !

Last post by woodguru « 28 Jun 2015, 11:00
Replies: 12
by woodguru » 26 Apr 2015, 09:40

Ever since I've had my T25 auto, there has been an issue when using the kickdown, occasionally it sticks down, ie, the pedal won't come back up,...

12 Replies

3724 Views

Last post by woodguru
28 Jun 2015, 11:00
mobile mechanic in south London?

Last post by ticket2ride « 27 Jun 2015, 11:39
Replies: 3
by ticket2ride » 26 Jun 2015, 09:01

Hello,

Does anyone know a reliable mechanic who could fit my refurbished carburetor? Happy to pay someone from here who knows how to do it.

Thanks.

3 Replies

1095 Views

Last post by ticket2ride
27 Jun 2015, 11:39
Simple 1y engine swap

Last post by Oldiebut goodie « 01 Jul 2015, 15:41
Replies: 5
by stevegandy » 26 Jun 2015, 12:48

Hi All im new here - ive just bought my first van, and within 3 hours of ownership managed to kill the engine (I didnt realise the dipstick wasnt...

5 Replies

2709 Views

Last post by Oldiebut goodie
01 Jul 2015, 15:41
Engine swap

Last post by oorwullie « 26 Jun 2015, 17:50
Replies: 1
by boxer » 26 Jun 2015, 08:16

Will this fit into a T25? probably more power than the 1.6 diesel.

onclick= window.open(this.href);return false;

Either way its a sweet looking...

1 Replies

997 Views

Last post by oorwullie
26 Jun 2015, 17:50
What bette non VW engine will drop straight into 1.6 diesel?

Last post by silverbullet « 27 Jun 2015, 22:12
Replies: 7
by Troopy » 26 Jun 2015, 13:49

As above, anyone got any suggestions as to a better engine that I can swap straight out without too much fuss?

7 Replies

2524 Views

Last post by silverbullet
27 Jun 2015, 22:12
How to fit steering rack bushes

Last post by JackE « 26 Jun 2015, 12:53
Replies: 19
by danmetallic » 16 Jul 2014, 09:19
1

2
Can anyone point me in the direction of a how to, pref with pictures (for a novice)? Thank you.
19 Replies

10604 Views

Last post by JackE
26 Jun 2015, 12:53
Removing 1.6td rocker cover, what's the secret? NOW OFF

Last post by Timeck « 26 Jun 2015, 08:04
Replies: 2
by Timeck » 25 Jun 2015, 06:34

I'm in the process of sorting out an oil leak and think I've narrowed it down to the rocker/ cam cover gasket. A simple task I thought... I loosened...

2 Replies

1209 Views

Last post by Timeck
26 Jun 2015, 08:04
Tracking

Last post by scunnerd25 « 25 Jun 2015, 20:35
Replies: 3
by dsmith1974 » 25 Jun 2015, 09:26

Noticed at the weekend that the offside front tyre was smooth (barely any tread left) along the outside edge (looks like within 75% of centre, so...

3 Replies

932 Views

Last post by scunnerd25
25 Jun 2015, 20:35
Coolant leaked from expansion tank?

Last post by Fully Loaded Cali' « 25 Jun 2015, 19:29
Replies: 6
by Fully Loaded Cali' » 25 Jun 2015, 16:48

Just been for a 5 mile drive up the motorway, got back, parked van up and about half a cup full of water came out top of expansion tank?? So, tested...

6 Replies

2138 Views

Last post by Fully Loaded Cali'
25 Jun 2015, 19:29
Fuel Line replacement

Last post by JessIvan « 25 Jun 2015, 15:16
Replies: 3
by JessIvan » 25 Jun 2015, 13:50

I've just bought a new fuel line and filter and was wondering what the best method of replacement is!
Do I need an empty tank or is there a way to...

3 Replies

1153 Views

Last post by JessIvan
25 Jun 2015, 15:16
2.1 fuel filter

Last post by Aidan « 25 Jun 2015, 04:20
Replies: 1
by batesy16 » 24 Jun 2015, 09:06

Anyone know if a 2.1 petrol fuel filter, will fit onto my 1.9dg engine.

1 Replies

866 Views

Last post by Aidan
25 Jun 2015, 04:20
Clutch woes

Last post by mines a money pit « 24 Jun 2015, 20:52

by mines a money pit » 24 Jun 2015, 20:52

My bus is in storage at the moment while I try and (slowly) sort all the issues out. It hadn't moved for a few months then needed to get it out to...

0 Replies

2078 Views

Last post by mines a money pit
24 Jun 2015, 20:52
1.6d cy engine number?

Last post by Oldiebut goodie « 24 Jun 2015, 15:46
Replies: 3
by pinpointer01 » 24 Jun 2015, 12:03

Can anyone tell me what vehicles the 1.6 d cy engines were fitted to? I have a cy engine and need to know if it would be a straight engine swap for...

3 Replies

2095 Views

Last post by Oldiebut goodie
24 Jun 2015, 15:46
Spark Plug popped out.

Last post by windydubber « 24 Jun 2015, 08:28
Replies: 7
by windydubber » 24 Jun 2015, 07:01

Last night, merrily driving along and had a loud pop and then more volume from the engine. Pulled over to see that
a Spark plug had popped out. I...

7 Replies

2087 Views

Last post by windydubber
24 Jun 2015, 08:28
Cheap exhaust

Last post by CovKid « 24 Jun 2015, 08:19
Replies: 35
by porthyt » 21 Apr 2015, 23:29
1

2

3
Hi,

Due to tight fund age at the moment (paying for loadsa welding). Where is the best place to get an exhaust from? I have 2.0 air cooled cu...
35 Replies

10365 Views

Last post by CovKid
24 Jun 2015, 08:19

New Topic

7574 topics

Page 123 of 152
- Jump to page:
Previous
1
…
121
122
123
124
125
…
152
Next

Return to Board Index

Forum permissions

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum