Mechanical

Moderators: User administrators, Moderators

7515 topics

Page 119 of 151
- Jump to page:
Previous
1
…
117
118
119
120
121
…
151
Next

Most liked posts	Author	Posted	Liked	Forum
Rear suspension wishbones: a cautionary tale	DevonAid	30 Jun 2025, 12:13	4 times this week	Mechanical
T25 servicing in Cumbria?	Oren Kipnis	Yesterday, 21:47	Once this week	Mechanical

Topics

Replies

Views

Last post

Help me decide - noisy tappet

Last post by JNW « 02 Aug 2015, 14:59
Replies: 9
by JNW » 27 Nov 2014, 07:40

Hello

I have a noisy hydraulic lifter - sounds like just one. The noise quietens after a long run, but comes back quite quickly. There's about 88k...

9 Replies

3214 Views

Last post by JNW
02 Aug 2015, 14:59
driveshaft bolts

Last post by CovKid « 01 Aug 2015, 19:32
Replies: 12
by dave lfc » 31 Jul 2015, 20:24

hi everyone just been driving home and driveshaft came out.luckily enough there was still one bolt hanging in the rubber so i could put it back on...

12 Replies

2978 Views

Last post by CovKid
01 Aug 2015, 19:32
will a 1.9dg engine bar fit a 2.0cu Aircooled engine. ?

Last post by nutbox « 01 Aug 2015, 18:03
Replies: 2
by nutbox » 01 Aug 2015, 14:11

Hi there.
As the title says ,are these engine bars interchangeable, because they look the same.
Cheers dazz

2 Replies

1131 Views

Last post by nutbox
01 Aug 2015, 18:03
Is this a reworked DJ to a DG ?

Last post by toolsntat « 01 Aug 2015, 07:23
Replies: 2
by toolsntat » 29 Jul 2015, 22:17

Was this possible?

Cheers
Andy

2 Replies

971 Views

Last post by toolsntat
01 Aug 2015, 07:23
1.9 diesel VAG engine conversion

Last post by Oldiebut goodie « 31 Jul 2015, 19:40
Replies: 3
by islandboy » 31 Jul 2015, 18:29

I'm going along, tomorrow, to look at a 1980 T25 Holdsworth Villa Conversion.

The advertiser states it has had 1.9 diesel VAG engine conversion....

3 Replies

1382 Views

Last post by Oldiebut goodie
31 Jul 2015, 19:40
nearside wiper spindle

Last post by islandboy « 31 Jul 2015, 16:28
Replies: 2
by islandboy » 27 Jul 2015, 10:30

I need to replace the nearside wiper spindle on my RHD 1985 T25 but google searches have been in vain, only showing up as discontinued item. Anyone...

2 Replies

918 Views

Last post by islandboy
31 Jul 2015, 16:28
Starter motor refurb sought, help needed.

Last post by Oldiebut goodie « 31 Jul 2015, 14:52
Replies: 2
by normal rules » 30 Jul 2015, 14:59

Ok so I have removed starter motor from van, checked brushes, given the relevant parts a clean and inspected it. Put back on and still starts...

2 Replies

1064 Views

Last post by Oldiebut goodie
31 Jul 2015, 14:52
Distributor drive gear not engaging

Last post by handsmann « 31 Jul 2015, 07:29
Replies: 16
by handsmann » 28 Jul 2015, 19:45
1

2
We have a 1985 van with a 1.9 WBX (DG) that I have been unable to get running for over three weeks now. Our mechanic took a look at it a week ago,...
16 Replies

9810 Views

Last post by handsmann
31 Jul 2015, 07:29
Power Loss

Last post by ghost123uk « 31 Jul 2015, 05:27
Replies: 9
by vwroyd » 29 Jul 2015, 21:39

Hi,

Tonight I was driving along a duel carriageway at about 65mph when I lost power.. I thought I had run out of petrol and had a gallon on me so I...

9 Replies

2143 Views

Last post by ghost123uk
31 Jul 2015, 05:27
1.6TD JX watercooled intercooler

Last post by dave friday « 31 Jul 2015, 04:52
Replies: 42
by Wedgbury » 26 Jul 2015, 17:43
1

2

3
After a bit of advice which I'm sure everybody won't mind :D

Looking on the forum and after speaking to a few people the engine change to a 1.9TDI...
42 Replies

27962 Views

Last post by dave friday
31 Jul 2015, 04:52
Bentley Manual

Last post by sallysparkle2 « 30 Jul 2015, 20:29

by sallysparkle2 » 30 Jul 2015, 20:29

Hi everyone,

I have a bit of a gearbox issue and it will probably need stripping down. I was advised to take a peep at the Bentley manual for this....

0 Replies

1582 Views

Last post by sallysparkle2
30 Jul 2015, 20:29
Blue Smoke on Start Up

Last post by ghost123uk « 30 Jul 2015, 17:04
Replies: 3
by crazymilk » 30 Jul 2015, 10:34

Just wondering what the prognosis may be with blue smoke on start up on my 1.9 DG Water Cooled Wasser?
Is it time to proceed with the EJ25 Subaru I...

3 Replies

1384 Views

Last post by ghost123uk
30 Jul 2015, 17:04
t25 lost water when stationary

Last post by R0B « 30 Jul 2015, 12:23
Replies: 3
by Semayrag » 30 Jul 2015, 08:46

hi all, ive just bought a t25, A reg, drove it 20 miles, no problem, engine heat was fine, got home, and all of a sudden i had loads of water pouring...

3 Replies

1154 Views

Last post by R0B
30 Jul 2015, 12:23
1.9 TDI AHU Top Dead Centre Advice

Last post by Bigjcc55 « 03 Aug 2015, 19:43
Replies: 9
by VirginAtlantic » 30 Jul 2015, 06:20

Hi I have an AHU 1.9 TDI engine and I'm looking to see if anyone has knowledge of the crankcase position for TDC on the pulley side?

I don't have...

9 Replies

6519 Views

Last post by Bigjcc55
03 Aug 2015, 19:43
How to....brake servo connection to manifold

Last post by paulandchez « 29 Jul 2015, 22:40

by paulandchez » 29 Jul 2015, 22:40

I'm in the process of upgrading my carbs to a set of drla's and I've got a set of these empi manifolds

onclick= window.open(this.href);return...

0 Replies

1599 Views

Last post by paulandchez
29 Jul 2015, 22:40
crank seal, timing belt side

Last post by itchyfeet « 29 Jul 2015, 20:40
Replies: 4
by newkid » 29 Jul 2015, 16:23

Ive stripped everything down ready to change this bar the crank pulley, is it a left hand or right hand turning bolt? Have checked but couldnt find...

4 Replies

1217 Views

Last post by itchyfeet
29 Jul 2015, 20:40
Starter motor verdict.

Last post by normal rules « 29 Jul 2015, 18:06
Replies: 4
by normal rules » 28 Jul 2015, 20:55

Ok. I've read the wiki. My baby n was starting intermittently at turn of key. The solenoid clicks so I believe it's doing what it should. I removed...

4 Replies

1053 Views

Last post by normal rules
29 Jul 2015, 18:06
Front bearings

Last post by shepster « 29 Jul 2015, 14:57
Replies: 3
by nicktennear » 29 Jul 2015, 09:26

About to replace discs using Brickwerks discs and thinking about bearings, found these on Amazon at a ridiculously cheap price. Used the seller...

3 Replies

1610 Views

Last post by shepster
29 Jul 2015, 14:57
Any ideas what this could be.

Last post by kevtherev « 29 Jul 2015, 12:48
Replies: 15
by normal rules » 28 Jul 2015, 17:26
1

2
Had my van for about 2 months and noticed this when I got it. It is not a wet patch but there is clearly something making Causing it.
Any ideas. I...
15 Replies

3495 Views

Last post by kevtherev
29 Jul 2015, 12:48
Can you test an engine on a shelf?

Last post by kevtherev « 29 Jul 2015, 10:04
Replies: 56
by DoubleOSeven » 19 May 2015, 19:43
1

2

3

4
Title: Purchasing 2nd hand engines
Van details: 1.9 DG engine (it's dead, it's not resting), 1984 Caravelle
Description: Replacement engine sat on...
56 Replies

12646 Views

Last post by kevtherev
29 Jul 2015, 10:04
Spring Compressors

Last post by crazymilk « 29 Jul 2015, 08:35
Replies: 3
by crazymilk » 28 Jul 2015, 12:33

Hi there
I am always spending far too much buggering around on my suspension with upgrades, repairs ect and always struggle removing the...

3 Replies

823 Views

Last post by crazymilk
29 Jul 2015, 08:35
G13 Coolant for T25?

Last post by Mmalkie « 28 Jul 2015, 21:06
Replies: 15
by family4t25 » 31 Aug 2014, 08:00
1

2
Hi,

I was a lurker on the external site while choosing which would be our first camper van and I appreciate all I have learnt reading since the...
15 Replies

16507 Views

Last post by Mmalkie
28 Jul 2015, 21:06
AMC head failure! Carnage!

Last post by silverbullet « 28 Jul 2015, 10:38
Replies: 12
by silverbullet » 27 Jul 2015, 19:51

Si at T3 volution passed this one to me for a postmortem under the bandsaw, so before I hack it up to see if the waterjackets are really any better...

12 Replies

3608 Views

Last post by silverbullet
28 Jul 2015, 10:38
Aircooled Engine Misfire and Oil Consumption. Engine Rebuild

Last post by mitchell72 « 28 Jul 2015, 09:55
Replies: 4
by mitchell72 » 27 Jul 2015, 13:27

Does anybody know of a good Aircooled engine rebuilder in the Grantham / Lincolnshire area. I have a 1982 2.0 CU Aircooled Viking/Explorer which has...

4 Replies

1671 Views

Last post by mitchell72
28 Jul 2015, 09:55
exhaust replacement TODAY PLEASE!!

Last post by wxm1873 « 28 Jul 2015, 06:29
Replies: 7
by star1320om » 27 Jul 2015, 00:26

We are catching a ferry on tuesday and the exhaust has just gone!.. A desperate plea if anyone knows anyone who would be willing to replace our...

7 Replies

2319 Views

Last post by wxm1873
28 Jul 2015, 06:29
Sourcing a part

Last post by kevtherev « 28 Jul 2015, 06:10
Replies: 11
by Spude » 25 Jul 2015, 21:51

I have a 1900 water cooled and the pipe that comes from the water pump to the block has a leak .I need to source the part any ideas where i could get...

11 Replies

1861 Views

Last post by kevtherev
28 Jul 2015, 06:10
Starter motor strip down problem

Last post by CovKid « 27 Jul 2015, 23:27
Replies: 3
by normal rules » 27 Jul 2015, 16:08

Can't get the two flathead screws on the end of the starter motor cap removed. Despite soaking in plus gas. Any help appreciated

3 Replies

941 Views

Last post by CovKid
27 Jul 2015, 23:27
Starter motor make and model number?

Last post by CovKid « 27 Jul 2015, 22:08
Replies: 13
by normal rules » 24 Jul 2015, 21:25

I have a 1985 1.9 dg transporter petrol (autosleeper vt20). does anyone know what make and model the starter motor is. i plan to remove it and...

13 Replies

4175 Views

Last post by CovKid
27 Jul 2015, 22:08
Juddering up hill

Last post by waltraud « 27 Jul 2015, 20:45
Replies: 9
by waltraud » 10 Aug 2014, 10:34

83 DG Westy with camping load and 4 people. Generally runs v well. When going up certain hills not necessarily steep it can start to judder a bit and...

9 Replies

4068 Views

Last post by waltraud
27 Jul 2015, 20:45
Temp gauge at three quarters after new stat, pump and coolan

Last post by ghost123uk « 27 Jul 2015, 06:29
Replies: 12
by CaseyCamper » 26 Jul 2015, 09:20

Hey guys n gals, I would really appreciate your help with an issue I'm having. So I replaced my thermostat (87° opening Febi Bilstein brand), water...

12 Replies

3247 Views

Last post by ghost123uk
27 Jul 2015, 06:29
clutch fork seized after engine replacement

Last post by stevie43_uk « 26 Jul 2015, 14:21
Replies: 8
by stevie43_uk » 23 Jul 2015, 20:22

Hi all,

I'm at the end of my tether !

I've recently replaced my engine , new clutch and bearing - put it all back together. - bled the clutch and...

8 Replies

1799 Views

Last post by stevie43_uk
26 Jul 2015, 14:21
reputable t25 mechanics

Last post by CovKid « 26 Jul 2015, 09:21
Replies: 2
by stokeseys1974 » 25 Jul 2015, 10:41

Hi all. Have a t25 1.9dg syncro. Need it serviced as it's cutting out and don't want to start messing with it myself.

So where do people go??? I...

2 Replies

980 Views

Last post by CovKid
26 Jul 2015, 09:21
Core Plug Popped On Today's Trip To Belgium

Last post by silverbullet « 25 Jul 2015, 14:40
Replies: 25
by Jus » 22 Jul 2015, 17:08
1

2
Hi, I wonder if anyone can advise. The family were all packed up and set for a ten day trip to Belgium in our '87 W/C 1.9 Petrol T25 when our core...
25 Replies

6496 Views

Last post by silverbullet
25 Jul 2015, 14:40
Unusual MOT failure......

Last post by toolsntat « 25 Jul 2015, 12:40

by toolsntat » 25 Jul 2015, 12:40

Well it passed as it happens but while in there it failed to select reverse :shock:

A bit of pushing and shoving and it was adjusted by a couple of...

0 Replies

1578 Views

Last post by toolsntat
25 Jul 2015, 12:40
Adjustable Push Rod Tubes - Watercooled 1.9dg

Last post by 123-jn « 24 Jul 2015, 17:57
Replies: 10
by adhoc1979 » 23 Jul 2015, 11:53

Afternoon,

Looking for some advice and guidance. Can you fit adjustable push rod tubes to a 1.9dg water cooled engine. I don't fancy having to...

10 Replies

3859 Views

Last post by 123-jn
24 Jul 2015, 17:57
Heater blowing cold air only

Last post by MidLifeCrisis « 24 Jul 2015, 09:23
Replies: 10
by Hoopy_Frood » 22 Jul 2015, 08:36

I took the van out for a shake down run last night and noticed that my hot air blower isn't putting out any warm air. My radiator is getting hot, and...

10 Replies

5390 Views

Last post by MidLifeCrisis
24 Jul 2015, 09:23
Clutch pedal dash-in repairs on the samba

Last post by Wychall « 24 Jul 2015, 06:55
Replies: 3
by silverbullet » 23 Jul 2015, 13:30

Not tried it myself just yet, but intend to try it before I have the dash out. Don't know if this technique works on rhd...

onclick=...

3 Replies

925 Views

Last post by Wychall
24 Jul 2015, 06:55
check fuel hoses and buy fire extinguisher

Last post by itchyfeet « 24 Jul 2015, 06:51
Replies: 7
by itchyfeet » 17 Jul 2015, 20:34

Reminder before you go on holls

2kg fire extingisher minimum, preferably two, anything less is not worth having.

onclick=...

7 Replies

2668 Views

Last post by itchyfeet
24 Jul 2015, 06:51
Leaking ATF

Last post by Elli « 23 Jul 2015, 22:37
Replies: 2
by Elli » 22 Jul 2015, 22:53

My Caravelle (see signature) has sprung an ATF leak from where the differential meets the engine.
I'm thinking it's an oil seal but I cannot for the...

2 Replies

953 Views

Last post by Elli
23 Jul 2015, 22:37
Clutch pipe ?

Last post by stevie43_uk « 23 Jul 2015, 20:24
Replies: 2
by stevie43_uk » 18 Jul 2015, 12:22

Hi All,

I think I've got a leak on my 1988 diesel clutch pipe.

I've had a look and it appears to be 6mm plastic pipe which runs all the way from...

2 Replies

885 Views

Last post by stevie43_uk
23 Jul 2015, 20:24
DG 1.9 End Float

Last post by itchyfeet « 23 Jul 2015, 18:47
Replies: 3
by p373r42 » 23 Jul 2015, 07:41

I have a DG 1.9 engine, it’s a Vege recon unit.
It’s never let me down but has always been very tapy and performance wasn’t great.
I’ve started to...

3 Replies

1861 Views

Last post by itchyfeet
23 Jul 2015, 18:47
2.1 DJ lumpy when coasting and 2nd throttle spring

Last post by mark « 23 Jul 2015, 18:32
Replies: 9
by Tyrone Shoelaces » 17 Jul 2015, 13:11

My 2.1L DJ (1990) started suffering from a problem a number of months ago: When I’m driving along in gear under no load (i.e. coasting) the engine...

9 Replies

2517 Views

Last post by mark
23 Jul 2015, 18:32
2.0 cu timing woes

Last post by alan.lane3 « 23 Jul 2015, 18:13
Replies: 4
by Richiee722 » 17 Jul 2015, 09:10

hi guys
Trying to get my van running properly.
Changed the usual plugs, leads etc
But still won't go over 50 and running hot.
I've set the timing at...

4 Replies

1381 Views

Last post by alan.lane3
23 Jul 2015, 18:13
push rod tube seals where from?

Last post by paperhouselad « 23 Jul 2015, 17:02
Replies: 3
by paperhouselad » 22 Jul 2015, 21:08

Need to replace the leaking push rod tube seals on on our 2.0 litre Aircooled, question is wheres best to order them from? want them to last a bit....

3 Replies

1062 Views

Last post by paperhouselad
23 Jul 2015, 17:02
T3 won't kick over

Last post by Simon james « 23 Jul 2015, 16:26
Replies: 3
by Simon james » 20 Jul 2015, 07:47

Hi
I've been away for two weeks just tried to start my 2 litre Aircooled and no joy
Motor is turning over but doesn't want to fire up battery seems...

3 Replies

1134 Views

Last post by Simon james
23 Jul 2015, 16:26
Re: 1.9DG Oil Filler Removal (Finally done!)

Last post by itchyfeet « 23 Jul 2015, 05:35
Replies: 12
by SamsBus2012 » 03 Feb 2015, 00:15

The oil filler pipe on Magnus has been porous for some time now ( at the lower bend) but I have now grown tired of replacing the self amalgamating...

12 Replies

3573 Views

Last post by itchyfeet
23 Jul 2015, 05:35
Leaking Fuel Tank

Last post by Tobias13 « 22 Jul 2015, 22:20
Replies: 13
by Tobias13 » 20 Jul 2015, 12:22

Hey all

So petrol tank is leaking, pretty sure its on the seams where they two halves meet.

Been looking at different sealer products and was...

13 Replies

4636 Views

Last post by Tobias13
22 Jul 2015, 22:20
Loose spark plugs

Last post by itchyfeet « 22 Jul 2015, 19:30
Replies: 1
by ethelred the ready » 22 Jul 2015, 19:24

Doing a mini service today and found one of the plugs was loose! I had heard a chuffing from engine for a while and assumed it was just a leaking...

1 Replies

798 Views

Last post by itchyfeet
22 Jul 2015, 19:30
Hi revs on idle

Last post by Oldiebut goodie « 22 Jul 2015, 16:33
Replies: 3
by JerryMaidstone » 19 Jul 2015, 20:28

Hi all, I own a 1984 water cooled 1900cc petrol camper. It starts first time and runs good, but, there's a problem if I'm stationery in traffic. The...

3 Replies

1511 Views

Last post by Oldiebut goodie
22 Jul 2015, 16:33
MOT pass then breakdown.

Last post by Oldiebut goodie « 22 Jul 2015, 16:28
Replies: 3
by Brian C. » 19 Jul 2015, 21:11

Hello everyone.As a new member can I please get your help.Passing the MOT is usually one of the highlights of the year from with my VW T25...

3 Replies

1379 Views

Last post by Oldiebut goodie
22 Jul 2015, 16:28

New Topic

7515 topics

Page 119 of 151
- Jump to page:
Previous
1
…
117
118
119
120
121
…
151
Next

Return to Board Index

Forum permissions

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum