Mechanical

Moderators: User administrators, Moderators

7575 topics

Page 30 of 152
- Jump to page:
Previous
1
…
28
29
30
31
32
…
152
Next

Most liked posts	Author	Posted	Liked	Forum
1.9 Carburettor Pics	Aidan	Today, 09:22	2 times this week	Mechanical
1987 DJ does not fit 1983 Cooling Pipes	Robsey	Yesterday, 23:05	Once this week	Mechanical

Topics

Replies

Views

Last post

Cooling system details

Last post by rollercoaster « 05 Aug 2021, 20:23
Replies: 8
by rollercoaster » 01 Aug 2021, 12:35

Been sorting my system,
found loads of issues.

Leftover after a fair bit of new bits:

What sealant to use on the rubber O ring,
sealing the coolant...

8 Replies

1034 Views

Last post by rollercoaster
05 Aug 2021, 20:23
Engine trouble.

Last post by TONYT25T25 « 05 Aug 2021, 20:12
Replies: 3
by golfingtam » 05 Aug 2021, 16:32

Engine ran ok for about 20 miles, then started to burn oil, lost all power and used a lot of oil. Topped-up oil, tested compressions all 125psi....

3 Replies

799 Views

Last post by TONYT25T25
05 Aug 2021, 20:12
Cold start procedure in warm weather

Last post by TONYT25T25 « 05 Aug 2021, 12:13
Replies: 5
by TONYT25T25 » 04 Aug 2021, 20:32

Not using the camper as much as I like to, but do take it for a run once or twice a week just to keep things ticking over. Warm day on Monday but...

5 Replies

802 Views

Last post by TONYT25T25
05 Aug 2021, 12:13
Stumble, stall under throttle

Last post by TONYT25T25 « 03 Aug 2021, 16:58
Replies: 25
by jospanner » 25 Jul 2021, 13:36
1

2
My van ('81 Aircooled 2.0) has been stumbling when opening up the throttle.
Previous owner had the timing advanced much further than spec (according...
25 Replies

2938 Views

Last post by TONYT25T25
03 Aug 2021, 16:58
Auto gearbox

Last post by Mawsy « 02 Aug 2021, 15:18
Replies: 3
by Mawsy » 31 Jul 2021, 08:46

Hi all, I have a 1989 Caravelle automatic, it has a 1.9 engine, changed from 2.1 before I got it.will it be possible to change the gearbox for a 7...

3 Replies

888 Views

Last post by Mawsy
02 Aug 2021, 15:18
Auto enthusiastic kick down

Last post by Mocki « 01 Aug 2021, 15:52
Replies: 6
by Mocki » 31 Jul 2021, 19:36

My 2.1carb auto needs very little encouragement to kick down a gear , even at 60mph .
The van was originally a 1.9dg and I swapped my trusted DJ with...

6 Replies

977 Views

Last post by Mocki
01 Aug 2021, 15:52
Gear linkage bush repair kit

Last post by Wearside wanderer « 01 Aug 2021, 11:28
Replies: 6
by Wearside wanderer » 31 Jul 2021, 20:19

For an 1989 T25 petrol.

Justkampers out of stock and other outlets are confusing saying it’s not suitable for my vehicle.
Would anyone be able to...

6 Replies

1012 Views

Last post by Wearside wanderer
01 Aug 2021, 11:28
CU engine - Mechanical Pump - Engine cutting out

Last post by BOXY « 31 Jul 2021, 17:07
Replies: 5
by BOXY » 11 Jul 2021, 21:06

Hi all. It's been a while but I've broken my van again.

Yesterday after spending a couple of weeks camping in Cornwall, the AA had to relay me...

5 Replies

1330 Views

Last post by BOXY
31 Jul 2021, 17:07
Lead replacemenr

Last post by TONYT25T25 « 31 Jul 2021, 10:20
Replies: 9
by pauljvw » 04 Jul 2021, 19:01

1984 1.9 wbx DF
Is it a good idea to put some redex lead replacement
fluid in the system occasionally, thanks

9 Replies

1250 Views

Last post by TONYT25T25
31 Jul 2021, 10:20
1988 T25 gear selection tricky (advice needed)

Last post by DoubleOSeven « 30 Jul 2021, 23:31
Replies: 4
by gazhall10 » 11 Jul 2021, 08:30

Hi
I am after some advice on which parts to replace as a starter regarding gear selection problems, finding first gear proves very difficult and it...

4 Replies

1154 Views

Last post by DoubleOSeven
30 Jul 2021, 23:31
Rocker cover oil leak with new gaskets

Last post by TONYT25T25 « 30 Jul 2021, 22:41
Replies: 13
by jospanner » 07 Jul 2021, 17:49

Hi, Just replaced the rocker cover cork gaskets on my CU engine, now got an oil leak on the left side.

In the vehicle's distant past, someone (don't...

13 Replies

2211 Views

Last post by TONYT25T25
30 Jul 2021, 22:41
Early vs late DG Engine

Last post by DoubleOSeven « 30 Jul 2021, 22:07
Replies: 11
by randamonia » 28 Jul 2021, 21:18

ok....so I have a replacement engine sitting with my mechanic after i cooked mine. I ordered a late model engine (1987 Komet), but it looks like I...

11 Replies

2474 Views

Last post by DoubleOSeven
30 Jul 2021, 22:07
Mobile mechanic or club member to set up dizzy/timing on 2.0 Aircooled t3

Last post by ajsimmo « 29 Jul 2021, 16:08
Replies: 3
by VW NUT » 04 Jul 2021, 12:20

Could anyone help please either recommend a mobile mechanic near chilton durham who could set timing on 2.0 Aircooled t3 or any club member who could...

3 Replies

1278 Views

Last post by ajsimmo
29 Jul 2021, 16:08
Oil leak on top of engine case

Last post by aknapper « 29 Jul 2021, 11:03
Replies: 4
by aknapper » 15 Jul 2021, 14:33

Hi everyone,
I'm getting some oil pooling on top of the engine case on the left side near the dizzy. I tightened the fuel pump and oil breather...

4 Replies

922 Views

Last post by aknapper
29 Jul 2021, 11:03
Engine oil light staying on

Last post by T25Convert « 28 Jul 2021, 21:58
Replies: 19
by fernsd » 25 Jul 2021, 13:58
1

2
Hi, my engine oil light was flashing. Just put in 1.5 litres of oil and the light is now staying on. Please could someone advice

Thanks,
Desmond
19 Replies

3336 Views

Last post by T25Convert
28 Jul 2021, 21:58
Coolant Pipe

Last post by randamonia « 28 Jul 2021, 21:04
Replies: 2
by randamonia » 28 Jul 2021, 20:24

Hi

Trying to source this pipe I am cleverly pointing to. Does anyone know what it's called, description, part number etc. and where I can get it...

2 Replies

305 Views

Last post by randamonia
28 Jul 2021, 21:04
MOT emissions results - very low CO%

Last post by keynsham1 « 28 Jul 2021, 08:05
Replies: 11
by bustrucket » 20 Jul 2021, 07:41

Hi all

I got an emissions check as part of the MOT which I wasn't expecting, but hey ho. Anyway it appears to show a very low CO of 0.15% which is...

11 Replies

1267 Views

Last post by keynsham1
28 Jul 2021, 08:05
Am I in trouble?

Last post by Bryce « 27 Jul 2021, 10:39
Replies: 6
by Bryce » 25 Jul 2021, 20:00

Hi its me yet again with another problem.

Blew the coolant cap off on sat and have replaced the the tank today as threads were stripped when I...

6 Replies

770 Views

Last post by Bryce
27 Jul 2021, 10:39
T25 Ignition Parts/Questions

Last post by pbar « 26 Jul 2021, 20:19
Replies: 15
by pbar » 25 Jul 2021, 17:31
1

2
Hi, I have a 1985 'C' plate T25 1.9 water cooled which I've had for a handful of years, Autohomes conversion (this forum has been brilliant reading...
15 Replies

1356 Views

Last post by pbar
26 Jul 2021, 20:19
1989 T25 sympathy & advice?

Last post by CaptainPugwash « 26 Jul 2021, 11:16
Replies: 5
by CaptainPugwash » 28 Jun 2021, 16:10

Hi All.
Well, I bought my 1989 T25 (1.9 Petrol) 5 years ago now - and had some friendly and helpful advice from the Club here at that time.
Now,...

5 Replies

545 Views

Last post by CaptainPugwash
26 Jul 2021, 11:16
Coolant catch 22?

Last post by Bryce « 22 Jul 2021, 19:20
Replies: 5
by Bryce » 20 Jul 2021, 10:34

Hi
I've recently found out my coolant temp sensor has gone kaput and have ordered a replacement.

From reading up I will have to refill the coolant...

5 Replies

736 Views

Last post by Bryce
22 Jul 2021, 19:20
Early exhaust / late cooling system compatibility?

Last post by bustrucket « 22 Jul 2021, 12:26
Replies: 7
by bustrucket » 20 Jul 2021, 13:07

My van ('83 DG manual) has the early exhaust & cooling set up, but the metal crossover pipe and a few other bits are bodged or have seen better...

7 Replies

546 Views

Last post by bustrucket
22 Jul 2021, 12:26
What's this noise? Clattering 2.0 Aircooled

Last post by Mona « 22 Jul 2021, 10:40
Replies: 8
by jospanner » 21 Jul 2021, 14:32

What's this noise? And what can I do about it?
OfQBy02AqRc

8 Replies

512 Views

Last post by Mona
22 Jul 2021, 10:40
Just another oil leak

Last post by Rosie n' Jim « 19 Jul 2021, 18:52
Replies: 1
by Jakew1610 » 19 Jul 2021, 17:37

Hey all

T25 2ltr air-cooled and she has an oil leak underneath. With myself not being too overly mechanically confident, can someone advise?

Only...

1 Replies

337 Views

Last post by Rosie n' Jim
19 Jul 2021, 18:52
Aircooled Knock under load.

Last post by Davegrohl99 « 17 Jul 2021, 10:32
Replies: 16
by Davegrohl99 » 11 Jul 2021, 16:23
1

2
Hey everyone,

Just back from a 900km trip around “Sunny south east” of Ireland.

I have noticed taking on some very steep hills under harsh...
16 Replies

1599 Views

Last post by Davegrohl99
17 Jul 2021, 10:32
100% coolant/antifreeze

Last post by jrt « 16 Jul 2021, 20:20
Replies: 2
by TONYT25T25 » 16 Jul 2021, 20:06

Watching a motor programme about refilling a car's cooling system with specialised coolant that has not water in it, mechanic removed the radiator...

2 Replies

346 Views

Last post by jrt
16 Jul 2021, 20:20
Missing expansion tank?

Last post by aknapper « 15 Jul 2021, 15:33
Replies: 49
by Bryce » 26 Jun 2021, 20:41
1

2

3

4
Hello again!

I have just got round to looking at topping up the coolant on my 1.6jx engine and read up on what coolant to what level etc.

I have...
49 Replies

4304 Views

Last post by aknapper
15 Jul 2021, 15:33
Vacuum pipes, CU 2.0 Aircooled

Last post by bigherb « 14 Jul 2021, 06:39
Replies: 2
by jospanner » 13 Jul 2021, 18:32

I have been fiddling with the vacuum pipes on my CU engined van. The vac advance didn't seem to be working.
Does this vacuum setup look correct? The...

2 Replies

308 Views

Last post by bigherb
14 Jul 2021, 06:39
1.9 DG Issues

Last post by Cheddies « 13 Jul 2021, 10:40
Replies: 5
by Kris2029 » 12 Jul 2021, 22:01

Good Evening Guys,

I'm new to the forum so Hey hope your all good!

I have a T25 1.9 DG it's been having issues with the fueling were the van would...

5 Replies

575 Views

Last post by Cheddies
13 Jul 2021, 10:40
-30mm spring load capacity?

Last post by Florence the Komet « 12 Jul 2021, 13:09
Replies: 2
by Florence the Komet » 12 Jul 2021, 10:46

Hi all. I have a 1989 Autohomes komet mk2 hightop T25 (2.1 DJ 5-speed manual). As i understand it, it's still on original springs (and original 14...

2 Replies

348 Views

Last post by Florence the Komet
12 Jul 2021, 13:09
Brake master cylinder

Last post by T25Convert « 11 Jul 2021, 22:04
Replies: 2
by T25Convert » 09 Jul 2021, 07:23

Hello,

I believe my master cylinder has failed, as the almost new fluid has turned black and the pedal is unpredictable (occasionally goes to floor,...

2 Replies

366 Views

Last post by T25Convert
11 Jul 2021, 22:04
Alternator Belt keeps snapping

Last post by R0B « 11 Jul 2021, 19:43
Replies: 4
by drippytap » 11 Jul 2021, 13:59

Any Suggestions please
In Sept 2017 my alt belt went on my 1.6td vw camper
First time probably it was replaced in say 10years
Since then it has...

4 Replies

562 Views

Last post by R0B
11 Jul 2021, 19:43
Upper wishbone bush

Last post by maxstu « 11 Jul 2021, 17:08
Replies: 7
by shrig1969 » 20 Jun 2021, 14:49

I have a very intermittent squeaky drivers side suspension noise.
I believe I have narrowed it down to the upper wishbone area.
Plastered it in...

7 Replies

812 Views

Last post by maxstu
11 Jul 2021, 17:08
Carburettor setup Leicestershire

Last post by Autosleeper_rich « 11 Jul 2021, 09:35

by Autosleeper_rich » 11 Jul 2021, 09:35

Help! Really struggling to find someone to set up my carb. Does anyone have any recommendations in the Leicestershire area?

Thanks

Sent from my...

0 Replies

2444 Views

Last post by Autosleeper_rich
11 Jul 2021, 09:35
Smelly engine

Last post by tobydog « 11 Jul 2021, 08:42
Replies: 17
by pauljvw » 04 Jul 2021, 15:46
1

2
Westy 1.9 wbx DF.
Hi, high mileage engine but regular servicing!
Could anyone suggest what might be the cause of the unpleasant smell from the...
17 Replies

1613 Views

Last post by tobydog
11 Jul 2021, 08:42
Leaking rocker covers

Last post by TONYT25T25 « 10 Jul 2021, 20:11
Replies: 1
by Jakew1610 » 10 Jul 2021, 19:47

Hey.

So the other day my t25 2.0 air-cooled was in for some engine maintenance to get it running better.
The rocker covers were removed to check...

1 Replies

296 Views

Last post by TONYT25T25
10 Jul 2021, 20:11
E10 Fuel?

Last post by R0B « 10 Jul 2021, 16:32
Replies: 1
by triumph2.5pi » 10 Jul 2021, 15:43

With the introduction of E10 fuel, what will you be running your T25 on? Will the higher ethanol content adversely affect our vans? Should I be using...

1 Replies

340 Views

Last post by R0B
10 Jul 2021, 16:32
New and confused

Last post by Dueller « 10 Jul 2021, 15:02
Replies: 12
by Jakew1610 » 30 Jun 2021, 20:49

Hi all.

Air-cooled t25 2.0 ltr in need of some love. Noob here too so please answer simply haha

Firstly she starts okay most of the time but...

12 Replies

1152 Views

Last post by Dueller
10 Jul 2021, 15:02
Topic: Slipping Auto

Last post by izzybarnard « 10 Jul 2021, 14:11
Replies: 12
by chris7ian » 04 Jul 2021, 12:00

Does anybody have any experience of a slipping Auto Gearbox?
My '89 2.1 MV auto seems to be suffering cross contamination of the ATF and Coolant: the...

12 Replies

1089 Views

Last post by izzybarnard
10 Jul 2021, 14:11
Crank shaft (rear) leak.

Last post by SurfT25 « 10 Jul 2021, 07:43
Replies: 16
by SurfT25 » 26 Jun 2021, 13:41
1

2
Had a slight leak for a while but recently got worse.
Top up now and again but not frequently, filter and oil change soon.
Cleaned and run engine...
16 Replies

1758 Views

Last post by SurfT25
10 Jul 2021, 07:43
Turbo Oil Return Hose

Last post by mrhutch « 09 Jul 2021, 23:06
Replies: 3
by Al3x147 » 09 Jul 2021, 16:00

Hi,

I have a 1.6TD 1983 Camper and need a hose to go between the Garrett turbo and the sump. I'm struggling to work out exactly what I need and how...

3 Replies

351 Views

Last post by mrhutch
09 Jul 2021, 23:06
1.6TD JX faulty LDA?

Last post by Forden341 « 09 Jul 2021, 14:57
Replies: 3
by jules18375 » 09 Jul 2021, 09:56

Can someone please confirm that I'm proceeding down a sensible route here!
Engine is a 1.6TD JX in a 1990 LHD T25

Symptoms. Potters along fine at...

3 Replies

1192 Views

Last post by Forden341
09 Jul 2021, 14:57
Changing the high pressure oil switch

Last post by Cheddies « 08 Jul 2021, 11:31
Replies: 9
by Cheddies » 05 Jul 2021, 07:46

Hey all.

Long time lurker, first time question-ner (most of the hundreds of questions I have had have been covered by the wiki/searching!).

1985...

9 Replies

988 Views

Last post by Cheddies
08 Jul 2021, 11:31
Header tank cap

Last post by TONYT25T25 « 08 Jul 2021, 10:25
Replies: 12
by TONYT25T25 » 15 Jun 2021, 12:02

Bought the following item from GSF as a spare after reading previous posts. The part was the listed for my vehicle but does not pass the test shown...

12 Replies

989 Views

Last post by TONYT25T25
08 Jul 2021, 10:25
Engine flooding with fuel. DJ2.1 1989 Auto. Broken down in roadside

Last post by weimarbus « 07 Jul 2021, 07:55
Replies: 99
by maxstu » 15 Jun 2021, 12:01
1

…

3

4

5

6

7
Before l call recovery. Any help please? I need to continue my journey.
On turning ignition key the fuel pump runs contantly and is flooding engine...
99 Replies

6262 Views

Last post by weimarbus
07 Jul 2021, 07:55
Carb Running Issue from cold

Last post by Dueller « 06 Jul 2021, 19:16
Replies: 2
by Dueller » 06 Jul 2021, 12:22

Hi everyone

Been through the Wiki and cant find an answer to this one

So ive rebuilt my late type 1.9 DG WBX engine and all is good, timed up well,...

2 Replies

314 Views

Last post by Dueller
06 Jul 2021, 19:16
clutch

Last post by Al Housman « 06 Jul 2021, 09:09

by Al Housman » 06 Jul 2021, 09:09

I have asked a question on the alternative engine site but really my query is not specific to my AAZ.

My gearbox will be with Aidan soon for some...

0 Replies

2468 Views

Last post by Al Housman
06 Jul 2021, 09:09
Water Pipe

Last post by kentishvanman « 06 Jul 2021, 06:45
Replies: 11
by kentishvanman » 05 Jul 2021, 15:00

1987 DG engine.
Metal water pipe between thermostat and water pump has a couple of bumps on it. Assume corrosion on inside?
Just a thought. What is...

11 Replies

698 Views

Last post by kentishvanman
06 Jul 2021, 06:45
Starting problem

Last post by TONYT25T25 « 05 Jul 2021, 22:22
Replies: 8
by lukeskywalker945 » 03 Jul 2021, 15:41

Hi everyone.

I’m hoping for some sound advice before going out and buying replacement parts that may not be needed.

I have a 1989 1.9 DG. It’s been...

8 Replies

740 Views

Last post by TONYT25T25
05 Jul 2021, 22:22
emergency spares

Last post by TONYT25T25 « 05 Jul 2021, 15:25
Replies: 3
by Freddievan » 05 Jul 2021, 14:11

What spares do you carry on a long adventure? I'll certainly include a spare aux belt after my last experience (and spare tyre obv)

3 Replies

456 Views

Last post by TONYT25T25
05 Jul 2021, 15:25

New Topic

7575 topics

Page 30 of 152
- Jump to page:
Previous
1
…
28
29
30
31
32
…
152
Next

Return to Board Index

Forum permissions

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum