Front to back rubber small bore coolant pipes
Moderators: User administrators, Moderators
Front to back rubber small bore coolant pipes
83 Early 1.9dg petrol
On the van there are two smaller rubber pipes that run from the front to the back. They are clipped to the two plastic feed and return pipes. One of them is weeping where it connects at the engine bay. However that is not my problem that is easily fixed.
My problem is that I have noticed a spherical chunk has been worn out of one. In a past life it looks like the pipe as sagged down and been worn by the driveshaft. So in that position the pipe is thin and is a weak point that will no doubt end up in future coolant loss. Maybe today, maybe next year, maybe never.
What are these pipes for......heater perhaps?
Are these pipes still available or are there any aftermarket solutions?
On the van there are two smaller rubber pipes that run from the front to the back. They are clipped to the two plastic feed and return pipes. One of them is weeping where it connects at the engine bay. However that is not my problem that is easily fixed.
My problem is that I have noticed a spherical chunk has been worn out of one. In a past life it looks like the pipe as sagged down and been worn by the driveshaft. So in that position the pipe is thin and is a weak point that will no doubt end up in future coolant loss. Maybe today, maybe next year, maybe never.
What are these pipes for......heater perhaps?
Are these pipes still available or are there any aftermarket solutions?
- Ian Hulley
- Registered user
- Posts: 12661
- Joined: 11 Oct 2005, 08:08
- 80-90 Mem No: 1323
- Location: Wirksworth, Derbyshire ... or at t'mill
Re: Front to back rubber small bore coolant pipes
They're the heater hoses, ask for 'GP80' hose from a proper hose retailer, tell then what it's for and they should sell you that or an equivalent off the roll. Obviously you'll need to measure the i.d. and the length you want.
Ian.
Ian.
The Hulley's Bus
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
Re: Front to back rubber small bore coolant pipes
Cheers Ian
Hose retailer. Would that include motor factors?
Someone on the birck-yard suggested the hose was 5/8" inner diameter and to cut the worn part off and clip a new piece using a steel tube and clips rather than changing the whole length
If that is the case I was thinking of some stainless pipe as a joining insert
http://cgi.ebay.co.uk/STAINLESS-316-tub ... 2a08eadbb1" onclick="window.open(this.href);return false;
Anyone changed one of these heater pipes and would know the size of the inner bore?
Hose retailer. Would that include motor factors?
Someone on the birck-yard suggested the hose was 5/8" inner diameter and to cut the worn part off and clip a new piece using a steel tube and clips rather than changing the whole length
If that is the case I was thinking of some stainless pipe as a joining insert
http://cgi.ebay.co.uk/STAINLESS-316-tub ... 2a08eadbb1" onclick="window.open(this.href);return false;
Anyone changed one of these heater pipes and would know the size of the inner bore?
- Oldiebut goodie
- Registered user
- Posts: 7503
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: Front to back rubber small bore coolant pipes
I wouldn't use stainless - think of the galvanic action. Keep the mixtures of metal simple.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
Re: Front to back rubber small bore coolant pipes
Isn't stainless all the rage for the van length feed and return rad pipes?
- Oldiebut goodie
- Registered user
- Posts: 7503
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: Front to back rubber small bore coolant pipes
I would prefer to keep the aluminium of my engine intact rather than add stainless.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
-
- Trader
- Posts: 8078
- Joined: 12 Oct 2005, 20:55
- 80-90 Mem No: 1948
- Location: lincolnshire
Re: Front to back rubber small bore coolant pipes
Nice bit of copper pipe to your liking then sir?
mike

mike
Re: Front to back rubber small bore coolant pipes
I have looked and the pipe has a connection before it enters the cab so I may as well change that whole length rather than just repair the section
Or am I making unnecessary work for myself?
E D I T: I found the number of the water pipe on etos and when I searched I found this site http://vegwerks.wordpress.com/category/volkswagen/" onclick="window.open(this.href);return false;
I know it says diesel but the pipes are the same bore size and they claim they are 5/8"

Or am I making unnecessary work for myself?
E D I T: I found the number of the water pipe on etos and when I searched I found this site http://vegwerks.wordpress.com/category/volkswagen/" onclick="window.open(this.href);return false;
I know it says diesel but the pipes are the same bore size and they claim they are 5/8"
(15) Heater Hose (Return) From Front – 3530mm – Connects to 3-Way Hose (6)
* ALL 251-265-057 (available but discontinued)
82 DIY: if this isn’t just a $225 (list price 02/2010) length of 5/8” hose, I don’t know what is! Most folks recommend about 30 feet of 5/8 hose to replace the stock heater hoses.

- Oldiebut goodie
- Registered user
- Posts: 7503
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: Front to back rubber small bore coolant pipes
metalmick8y wrote:Nice bit of copper pipe to your liking then sir?![]()
mike
Aluminium will be highly anodic to the stainless steel cathode; it is slightly less anodic to the copper.

Last edited by Oldiebut goodie on 02 Aug 2010, 22:04, edited 1 time in total.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
-
- Trader
- Posts: 8078
- Joined: 12 Oct 2005, 20:55
- 80-90 Mem No: 1948
- Location: lincolnshire
Re: Front to back rubber small bore coolant pipes
I know it is , but there int a "tongue in cheek" smilie
mike
mike

Re: Front to back rubber small bore coolant pipes
Will somewhere like unipart have the General Purpose 80 hose in 5/8" diameter?
I ask because we have one in Preston
I ask because we have one in Preston
-
- Trader
- Posts: 8078
- Joined: 12 Oct 2005, 20:55
- 80-90 Mem No: 1948
- Location: lincolnshire
Re: Front to back rubber small bore coolant pipes
any of the half decent motor factors should stock it, its pretty standard stuff
mike
mike
-
- Trader
- Posts: 3152
- Joined: 08 Oct 2005, 19:36
- 80-90 Mem No: 1
- Location: Huddersfield, WeYo.
- Contact:
Re: Front to back rubber small bore coolant pipes
Oldiebut goodie wrote:metalmick8y wrote:Nice bit of copper pipe to your liking then sir?![]()
mike
Aluminium will be highly anodic to the stainless steel cathode; it is slightly less anodic to the copper.
But does it really matter.
heard lots of "engineers" mention this, yet the septics (you know how they like to go on and on and on and on about every minute detail) sell them and fit them in large numbers as do the Germans.
No metal parts are touching each other, they are insulated at either end by rubber.
Yet to see any evidence, or proof that using stainless in a cooling system is such a bad idea.
It's a subject I know very little about, but I always though this problem is when different metals come INTO CONTACT with each other and the corrosion between the 2 metals but if the parts are insulated and a good quality coolant used is there any need for concern, and if there is need for concern exactly how long are the effects going to take to appear, days, months? years? and if there are any effects what will they be? head studs corroding on WBXs' ? they do that on their own!!
Sitting back awaiting to be edumucated...

Re: Front to back rubber small bore coolant pipes
I thought so but I had to have my blonde momentmetalmick8y wrote:any of the half decent motor factors should stock it, its pretty standard stuff
mike

- Oldiebut goodie
- Registered user
- Posts: 7503
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: Front to back rubber small bore coolant pipes
Having seen a lot of nasties in boats with the effects of various fluids in contact with stainless I am always wary of setting up a circuit with totally dissimilar metals. The circuit is made through the liquid - the metals do not have to be in contact.
A favourite for corrosion is stainless steel tubing in a water cooled exhaust - usually a jointing piece in rubber exhaust pipes. Admittedly a vehicle is not exactly the same as a marine situation but there are still electrical connections via the fluids.Best to stick with the same materials as are already present to lessen the effect. As to whether we will get 30 years out of the stainless/ aluminium combination without losing the integrity of the waterways we will have to wait and see. (doubt I will be around to see though - or even care then if I am!
)
A favourite for corrosion is stainless steel tubing in a water cooled exhaust - usually a jointing piece in rubber exhaust pipes. Admittedly a vehicle is not exactly the same as a marine situation but there are still electrical connections via the fluids.Best to stick with the same materials as are already present to lessen the effect. As to whether we will get 30 years out of the stainless/ aluminium combination without losing the integrity of the waterways we will have to wait and see. (doubt I will be around to see though - or even care then if I am!

1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶