Tappets

Big lumps of metals and spanners.

Moderators: User administrators, Moderators

Locked
Steve Goddard
Registered user
Posts: 62
Joined: 19 Sep 2008, 10:43
80-90 Mem No: 0
Location: Buxton

Tappets

Post by Steve Goddard »

Can anyone tell me what the settings are on a watercooled 1900 and if its not a totally stupid question,looking from above which are the inlet and which are exhaust?
:?

User avatar
kevtherev
Registered user
Posts: 18832
Joined: 23 Oct 2005, 20:13
80-90 Mem No: 2264
Location: Country estate Wolverhampton Actually

Re: Tappets

Post by kevtherev »

settings are zero lash (zero gap) then 1 1/2 turns in at TDC compression stroke for both inlet and exhaust.
some set it at 1/2 turn in from zero, some use 1 turn in... Bently and haynes say two turns in, there's a lot of discussion on this

This is a must read artical.... http://www.ratwell.com/technical/HydraulicLifters.html" onclick="window.open(this.href);return false;

the lifters should be pumped up with a short run and a warmish engine

if you look at the manifold you can see the inlets (both together?)
and the exhausts are... on the out side where the exhaust comes out of the head!

unless you have a reconditioned engine with solid lifters, there should be a sticker on your pancake duct that tells you if it has solid lifters

if you search on this forum (tech) there's loads of info.. or in the Archive
AGG 2.0L 8V. (Golf GTi MkIII)

Steve Goddard
Registered user
Posts: 62
Joined: 19 Sep 2008, 10:43
80-90 Mem No: 0
Location: Buxton

Re: Tappets

Post by Steve Goddard »

Thanks Kev :D

Steve Goddard
Registered user
Posts: 62
Joined: 19 Sep 2008, 10:43
80-90 Mem No: 0
Location: Buxton

Re: Tappets

Post by Steve Goddard »

By the way the reason Im asking is that I fitted a spring loaded pushrod tube as I had a seal leaking. after I reassembled the rocker gear I found it was running very badly and the two plugs on the side I was working on were cold and wet and the opposite were dry and warm.
All plugs ok and recently replaced as were the leads. Admittedly the fuel was very low and I had to go to the garage for a can full.
When I looked for clearance at the tappets there was none.I wondered if the pushrods were seated properly or were not in the cups.
Removing either of the plug leads on the left side made no difference to the running of the motor.
It also started with a bang. :(

User avatar
kevtherev
Registered user
Posts: 18832
Joined: 23 Oct 2005, 20:13
80-90 Mem No: 2264
Location: Country estate Wolverhampton Actually

Re: Tappets

Post by kevtherev »

I hope you did seat the pushrods right :shock:
AGG 2.0L 8V. (Golf GTi MkIII)

User avatar
Yozza
Registered user
Posts: 45
Joined: 15 Oct 2008, 19:28
80-90 Mem No: 6195
Location: Stoke-on-Trent

Re: Tappets

Post by Yozza »

Seating those pushrods requires a torch and a well squinted eye, it's one of those jobs that is much easier to get wrong than right. Once you've done them check them all, they quite often fall out while you're positioning the others :(
Good luck
T25 '90 2.1i 16" Doka
JCB 3C MkII
Thwaites 6000

Steve Goddard
Registered user
Posts: 62
Joined: 19 Sep 2008, 10:43
80-90 Mem No: 0
Location: Buxton

Re: Tappets

Post by Steve Goddard »

Your not kidding yozza,its like trying to juggle soot!

Locked