T25 Diesel Reimo

[spiket25]

hi and happy new year to all.

Bought this van on new years eve in the dark, yes i know not the best idea, but in the cold light of day not bad at all.

Bought this as a 1.9 N/a diesel after rubbing down the block under no3 injector the code is cs surely its a 1.6 diesel.




Dont know if you can see these images.

Any help on this matter would be very helpful

Cheers Spike

[peasant]

yepp ...cs is the 1.6 non turbo engine code and the rocker cover also looks very much 1.6

[spiket25]

Thanks peasant just trying to re asure my self that it is, the reg docs says different.

Pulls very well for a 1.6 n/a need to change cam belt previous owner has no idea when it was done.

Thanks for your help

[Louey]

need to change cam belt

Can be done in situ, replace the tensioner too. Have you done a cambelt before?? These are quite easy.

[spiket25]

Have not done it before louey but always up for a challenge just want to make sure i buy the right parts from mr baxter.
Not sure about this fuel filter ether any thoughts on it is it the screw in type.


Cheers spike

[Oldiebut goodie]

Look on the side of the crankcase under the manifolds - if it is a CS it will be 1.6 moulded in the casting. Certainly looks like a CS.The engine no. can be re-stamped but not so easy to change the crankcase moulding. (if anyone should really wish to for some strange reason)

[spiket25]

Thanks oldie check that out in the light of day definitely got cs stamped under the injector.

Thanks for your help Spike

[spiket25]

Update took the tinware of and a big 1.6d stamped on the crankcase
Thanks to all who helped steer me in the right direction.

Spike

[Louey]

Not sure about this fuel filter ether any thoughts on it is it the screw in type.

Unscrew old one

fill new one at least half full with diesel,
smear a bit on the rubber seal
screw back on
Undo the screw on top of the filter housing a little bit (its an air bleed screw)
turn over engine a few times - if it starts let it run
tighten screw
repeat if engine runs a bit lumpy or air in the clear bit of fuel pipe that runs to the fuel pump on engine)

[spiket25]

Thanks louey just what I needed to know parts arriving from mr baxters emporium tomorrow.
Cheers Spike