Spinning sump plug
Moderators: User administrators, Moderators
- kevtherev
- Registered user
- Posts: 18832
- Joined: 23 Oct 2005, 20:13
- 80-90 Mem No: 2264
- Location: Country estate Wolverhampton Actually
Spinning sump plug
I have discovered a spinning sump plug
Although it's not leaking and I can dump the oil if desperate, from the filler flange.. it wont undo or do up, and it would make life easier if it did.
So how do you get it out?
ideas would be helpfull
Although it's not leaking and I can dump the oil if desperate, from the filler flange.. it wont undo or do up, and it would make life easier if it did.
So how do you get it out?
ideas would be helpfull
AGG 2.0L 8V. (Golf GTi MkIII)
- TEMPO
- Registered user
- Posts: 34
- Joined: 27 Aug 2008, 06:30
- 80-90 Mem No: 5818
- Location: BIRKENHEAD,WIRRAL
Re: Spinning sump plug
Hi Kev,
you can get spanners that undo on the flat rather than on corners,
Think Halfords have them.Unlike most ring spanners, they have raised edges between corners.
Also, pair of stilsons may help ???? I would give the plug a few sharp taps first and a bit of release oil.
My final solution is the best, and i have done it.
When Kwik Fit have an oil change offer on, take it there, They will get it out.
you can get spanners that undo on the flat rather than on corners,
Think Halfords have them.Unlike most ring spanners, they have raised edges between corners.
Also, pair of stilsons may help ???? I would give the plug a few sharp taps first and a bit of release oil.
My final solution is the best, and i have done it.
When Kwik Fit have an oil change offer on, take it there, They will get it out.
5818 TEMPO BOUGHT VAN OFF A FRIEND,SOME FRIEND I HEAR YOU CRY :+)
- Ian Hulley
- Registered user
- Posts: 12661
- Joined: 11 Oct 2005, 08:08
- 80-90 Mem No: 1323
- Location: Wirksworth, Derbyshire ... or at t'mill
Re: Spinning sump plug
What's the oil's history ? I change our's at 4,000 these days, or by ear .... filter every other change.
I would heartily recommend NOT going to S**t F*t even to check the tyre pressures.
Ian
I would heartily recommend NOT going to S**t F*t even to check the tyre pressures.

Ian
The Hulley's Bus
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
-
- Trader
- Posts: 9020
- Joined: 09 Oct 2005, 17:31
- 80-90 Mem No: 1967
- Location: Sutton in'it Syncronaut: 123
- Contact:
Re: Spinning sump plug
kevtherev wrote:I have discovered a spinning sump plug
Although it's not leaking and I can dump the oil if desperate, from the filler flange.. it wont undo or do up, and it would make life easier if it did.
So how do you get it out?
ideas would be helpfull
This happened to Timthetrader when i first met him. He had the sump taken off and retapped by a garage near him for not very much money. Just to be safe in the mean time to get him home i bent a thick tent peg and used the tin wear bolt to fasten it in place to hold the plug in place so it couldnt fall out. When the garage did the job for him they put the tent peg back thinking it was part of the engine arrangement



jed
- T'Onion
- Moderator
- Posts: 10812
- Joined: 07 Oct 2005, 17:39
- 80-90 Mem No: 255
- Location: Sheffield or 07737167005
Re: Spinning sump plug


use a flat screwdriver and a spanner , prise the nut slightly with the driver and try winding it out. But what will you do after ? helicoil ? or try retapping with one slightly bigger ?
victus in mutuo vicis
Ego mori tu mori
Ego mori tu mori
- Mocki
- Membership Admin
- Posts: 17288
- Joined: 29 Sep 2005, 09:27
- 80-90 Mem No: 428
- Location: Mansfield Notts
- Contact:
Re: Spinning sump plug
heli coil is the only answer me thinks...... but there wont be no taking the sump off!
you are kidding me this is the first time you have dropped the oil since fitting? right?
you are kidding me this is the first time you have dropped the oil since fitting? right?

Steve
tel / txt O7947-137911

________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Auto Caravelle TS TinTop Camper
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Auto Caravelle TS TinTop Camper
- kevtherev
- Registered user
- Posts: 18832
- Joined: 23 Oct 2005, 20:13
- 80-90 Mem No: 2264
- Location: Country estate Wolverhampton Actually
Re: Spinning sump plug
Mocki wrote:heli coil is the only answer me thinks...... but there wont be no taking the sump off!
you are kidding me this is the first time you have dropped the oil since fitting? right?
OK to clarify
The engine was sat on a lifting bench. (being painted

So the old oil was drained out by taking the filler tube off as I couldn't hold the engine up safely to undo the plug.
I refitted the tube and filled the engine with fresh oil
It was only trying to fit an oil pressure gauge and wanting to let out some oil it has come to light.
I will try the prying method, if it succeeds ... then drill it part way in, and tap
thanks fellas
AGG 2.0L 8V. (Golf GTi MkIII)
-
- Registered user
- Posts: 1628
- Joined: 17 Jul 2006, 22:51
- 80-90 Mem No: 380
- Location: Ormskirk, Lancashire
Re: Spinning sump plug
If it is turning and won't come out watch out during the prying process coz the chances of shagging the sump are pretty good with it being alloy....
What you might find is that some dozzy cuunt has helicoiled it in the past and it is the insert and the plug which is spinning together in the casing,,,,,,,,,,,,,,If it was my problem I would be welding summat to the sump plug and then with the aid of a puller,,,,slowly unwind and pull at the same time..........and with luck it should come out...
Once it is out you may find the new hole is too large to re fit a VW sized plug......so an alternative will have to be found ( Vauxhall oil way blanking plugs are a good choice).
Taping the crank case from the underside ( as if the motor is installed) to prevent swarf from getting where the sun doesn't shine, will help, then flush any excess out with cheap flushing oil or diesel.
Regards
Fritz,,,,,,,,,
What you might find is that some dozzy cuunt has helicoiled it in the past and it is the insert and the plug which is spinning together in the casing,,,,,,,,,,,,,,If it was my problem I would be welding summat to the sump plug and then with the aid of a puller,,,,slowly unwind and pull at the same time..........and with luck it should come out...

Once it is out you may find the new hole is too large to re fit a VW sized plug......so an alternative will have to be found ( Vauxhall oil way blanking plugs are a good choice).
Taping the crank case from the underside ( as if the motor is installed) to prevent swarf from getting where the sun doesn't shine, will help, then flush any excess out with cheap flushing oil or diesel.
Regards
Fritz,,,,,,,,,
One day you will find me,,
Driving in my Camper,
With a Surf and Paisley wrap on both sides....
Driving in my Camper,
With a Surf and Paisley wrap on both sides....
Re: Spinning sump plug
can't you just put the sump on off the 1.9 kev then sort it at your leisure?
LT owner and positively rattling around with the new found space
member 3339
member 3339
-
- Registered user
- Posts: 1735
- Joined: 12 Oct 2005, 11:14
- 80-90 Mem No: 1342
- Location: Wolverhampton.
Re: Spinning sump plug
T'Onion wrote:you didnt check this before you put it in ? too busy painting it
![]()
As the fat man once said "You took the words right out of my mouth"
2.1 DJ running on carb and LPG.
- T'Onion
- Moderator
- Posts: 10812
- Joined: 07 Oct 2005, 17:39
- 80-90 Mem No: 255
- Location: Sheffield or 07737167005
Re: Spinning sump plug
Rozzo , there isn't a sump as such on a flat four , its the two half's of the casing ,Rozzo wrote:can't you just put the sump on off the 1.9 kev then sort it at your leisure?
Kev try two drivers and a extra hand to wind the plug out

victus in mutuo vicis
Ego mori tu mori
Ego mori tu mori
- Ian Hulley
- Registered user
- Posts: 12661
- Joined: 11 Oct 2005, 08:08
- 80-90 Mem No: 1323
- Location: Wirksworth, Derbyshire ... or at t'mill
Re: Spinning sump plug
Rozzo wrote:can't you just put the sump on off the 1.9 kev then sort it at your leisure?
Kinell J when was the last time you changed your oil ?

The d****ls have a pan sump same as a 'normal' engine, but like Mark say's on the flat fours it's part of the case casting.
Ian.
The Hulley's Bus
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
- jamesc76
- Registered user
- Posts: 6241
- Joined: 14 Oct 2005, 14:42
- 80-90 Mem No: 1186
- Location: Nottingham
- Contact:
Re: Spinning sump plug
Ian Hulley wrote:Rozzo wrote:can't you just put the sump on off the 1.9 kev then sort it at your leisure?
Kinell J when was the last time you changed your oil ?![]()
The d****ls have a pan sump same as a 'normal' engine, but like Mark say's on the flat fours it's part of the case casting.
Ian.
It is a proper sump on a scooby

DJ at Dubdayz Summerfest
Now cutting about in an LT35 MWB
Now cutting about in an LT35 MWB
- kevtherev
- Registered user
- Posts: 18832
- Joined: 23 Oct 2005, 20:13
- 80-90 Mem No: 2264
- Location: Country estate Wolverhampton Actually
Re: Spinning sump plug
right ho
I shall do it after the the European wessiefaliure tour.
for now it's pending
which fat man said that shep?
I shall do it after the the European wessiefaliure tour.
for now it's pending

which fat man said that shep?

AGG 2.0L 8V. (Golf GTi MkIII)
-
- Trader
- Posts: 3151
- Joined: 08 Oct 2005, 19:36
- 80-90 Mem No: 1
- Location: Huddersfield, WeYo.
- Contact:
Re: Spinning sump plug
I don't bother with helicoils or timeserts, I'm forever removing sump plugs with the bleeding things attached to the sum plug.
I tap the sump to M16 and fit a new plug, you can go as far as M18 if needed, but thats the last chance before it's mega bucks to sort out.
I tap the sump to M16 and fit a new plug, you can go as far as M18 if needed, but thats the last chance before it's mega bucks to sort out.