Alternator exciter cable voltage

An alchemy of sparks, copper wire and earth

Moderators: User administrators, Moderators

Post Reply
mueslibarkid
Registered user
Posts: 3
Joined: 19 Jun 2013, 22:09
80-90 Mem No: 0

Alternator exciter cable voltage

Post by mueslibarkid »

Hi could anyone confirm the required voltage on the blue exciter cable. I have around 4.5 volts at present. The battery warning light stays on and the alternator is not charging. I assume it should be around 12v. If this is the case I am assuming a high resisistance somewhere in the charging circuit.

Thanks for your help.
1989 1.6 TD Hightop Westy California.

dave friday
Registered user
Posts: 804
Joined: 15 Oct 2006, 11:19
80-90 Mem No: 5533
Location: rambler de oria, near albox,almeria,spain

Re: Alternator exciter cable voltage

Post by dave friday »

When the alternator is working correctly the blue wire should have the same voltage as the battery positive (13.5/14.5)
I dont think, so I'm not[do I exist?]
1992 1600td [ jx ] syncro panel van[leisuredrive camper ]

User avatar
Oldiebut goodie
Registered user
Posts: 7490
Joined: 18 Apr 2008, 01:19
80-90 Mem No: 11135
Location: Eastern Angle

Re: Alternator exciter cable voltage

Post by Oldiebut goodie »

On these alternators you need at least a 2w bulb charge indicator light - too low a current and the alternator will not perform correctly. 4.5v should be enough voltage to start the alternator charging but if you have low current at the same time you can have problems, seems like you have problems with the blue wire - highly likely to be corrosion. I would remake the terminal at the alternator end of it for a start.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶

mueslibarkid
Registered user
Posts: 3
Joined: 19 Jun 2013, 22:09
80-90 Mem No: 0

Re: Alternator exciter cable voltage

Post by mueslibarkid »

Thanks for your advice, I will take a look again later and remake the crimp connector.

Cheers Stephen
1989 1.6 TD Hightop Westy California.

User avatar
Oldiebut goodie
Registered user
Posts: 7490
Joined: 18 Apr 2008, 01:19
80-90 Mem No: 11135
Location: Eastern Angle

Re: Alternator exciter cable voltage

Post by Oldiebut goodie »

What are you using as an earth point when you are getting the 4.5v? Try with using the alternator body and then with the chassis - if there is any difference your earthing points need cleaning up/replacing.
Also the problem may well be the voltage regulator as this uses the trigger voltage to tell the output of the alternator to increase.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶

mueslibarkid
Registered user
Posts: 3
Joined: 19 Jun 2013, 22:09
80-90 Mem No: 0

Re: Alternator exciter cable voltage

Post by mueslibarkid »

Hi thanks for all the advice. I recrimped the exciter cable connection and the spade terminal connection and the problem is solved.

Cheers!
1989 1.6 TD Hightop Westy California.

Post Reply