Just thought I'd try and add up some of what iv spent so far to give others a idea of what it can be done for , some prices might be slightly out as I'm doing it from memory lol
Some parts iv had to buy I will leave out as most vans come with them like the clutch system as iv had to swap it all to hydrolic as mine was cable but this only added up to around £100
So far
Rjes bell housing and Gearbox spline = £500 ,second hand
Rjes engine mount bar = £165
Rjes gearbox mount kit =£50
Rjes throttle cable = £40
Rjes reversed coolant crossover = £50
Rjes coolant fitting kit = £95
Rjes VSS = £45
Front to rear coolant pipes and rad = £100 second hand
Turbo engine = £150 = car purchased for 350 and manual gearbox sold for 200
Rjes loom conversion = £400
Shortened Subaru sump =£250 (waiting to be made)
Exhaust is a turbo flange and strait pipe = £50
Fuel pump and filter = £50
New injection petrol tank = £90
New fuel hose = £20
Still a few things to buy to get it finished so I will add things as I go and do a full total at the end , if there is a end lol
Prob a few things iv forgotten to add on as the always is like fixings and the shiny bits that seem to get added as you go but so far it works out to just over £2055 , this could of been cut down by quite a bit by buying the right van to start with but as I didn't know the VW very well I just went for what I thought would be OK , but I'm still very happy with my van and plan to keep it for the foreseeable future
