Possible sticking thermostat?

Big lumps of metals and spanners.

Moderators: User administrators, Moderators

Locked
newkid
Registered user
Posts: 58
Joined: 27 Dec 2013, 15:06
80-90 Mem No: 13142
Location: Edinburgh

Possible sticking thermostat?

Post by newkid »

My mums 1.6 diesel has had just about every water component changed over the last 12 months, water pipes to stainless steel, new water pump, new radiator and switch. Today I bleed the system till no more bubbles are coming out the new radiator, the heaters are getting slightly warm and the new needle after idling for 30 minutes gets to just about the area marked with the white line. If you go for a short drive the needle gets were the red warning light is. Once you stop and it sits idling again the temperature needle drops back down to the white marker. I've checked both pipes at the radiator and even straight after the short drive both are stone cold, the pipes in the engine bay are hot but not to hot to touch. Could it be the thermostat (the only part I haven't changed) is sticking open and causing the system not to stay at optimum temperature.

Cheers.

User avatar
kevtherev
Registered user
Posts: 18832
Joined: 23 Oct 2005, 20:13
80-90 Mem No: 2264
Location: Country estate Wolverhampton Actually

Re: Possible sticking thermostat?

Post by kevtherev »

If the thermostat stays open then the temperature would never reach optimum.
It would languish at the cooler end of the scale

I've checked both pipes at the radiator and even straight after the short drive both are stone cold
this suggests the thermostat has not opened, or you simply have not drove it long enough to get the coolant up to temp

The heater circuit has nothing to do with the radiator circuit, it comes directly off the engine at No1 cyl. through the coolant distributor
If the heater matrix is not getting hot then there is a blockage (gunk) or the valve has not opened properly... or the thermostat is stuck open

If you go for a short drive the needle gets were the red warning light is
This is confusing as it describes where the needle should sit under normal conditions.
If the needle drops lower then the thermostat isn't closing
AGG 2.0L 8V. (Golf GTi MkIII)

newkid
Registered user
Posts: 58
Joined: 27 Dec 2013, 15:06
80-90 Mem No: 13142
Location: Edinburgh

Re: Possible sticking thermostat?

Post by newkid »

Not sure if this helps Kev, both pipes at the radiator were stone cold, no heat at all. The 2 thinner pipes at the heater matrix were hot. when driving and the needle in the middle the heater blew hot, when we stopped and starting idling again the heater still blew hot but not as hot and the needle was dropping, if u gave it a rev the heater got hotter.

User avatar
kevtherev
Registered user
Posts: 18832
Joined: 23 Oct 2005, 20:13
80-90 Mem No: 2264
Location: Country estate Wolverhampton Actually

Re: Possible sticking thermostat?

Post by kevtherev »

Again the heater matrix is drawing coolant from the engine, if the heat drops away, then either the flow through it is too slow or the thermostat is fully open or it's gunked up...

So if the rad hoses are cold then the thermostat hasn't opened or the rad is blocked.

there are two confusing pieces of information here.
Time to eliminate the obvious
Take the stat out and test it
AGG 2.0L 8V. (Golf GTi MkIII)

User avatar
kevtherev
Registered user
Posts: 18832
Joined: 23 Oct 2005, 20:13
80-90 Mem No: 2264
Location: Country estate Wolverhampton Actually

Re: Possible sticking thermostat?

Post by kevtherev »

Image

test
opens at 87 deg iirc
AGG 2.0L 8V. (Golf GTi MkIII)

newkid
Registered user
Posts: 58
Joined: 27 Dec 2013, 15:06
80-90 Mem No: 13142
Location: Edinburgh

Re: Possible sticking thermostat?

Post by newkid »

Im a little lost here, the radiator is brand new so I would presume that eliminates it from being gunked up, also bleeding the radiator was extremely easy, with the revs held at about 2k the bubbles pushed out and then we had a steady flow of coolant.

User avatar
Oldiebut goodie
Registered user
Posts: 7502
Joined: 18 Apr 2008, 01:19
80-90 Mem No: 11135
Location: Eastern Angle

Re: Possible sticking thermostat?

Post by Oldiebut goodie »

kevtherev wrote:
The heater circuit has nothing to do with the radiator circuit, it comes directly off the engine at No1 cyl. through the coolant distributor

Forward end of the cylinder head - it's a diseasel. :)
Sounds like the thermostat is stuck open to me also.
Be prepared for a possible replacement of the plastic thermostat housing as several people have found that they are distorted with age and heat and it is nigh on impossible to get it to seal correctly again. Mine was oval when removed and prevented the o-ring sealing fully, others have found that the face is distorted out of true and also causes trouble with the seal. Available from Brickwerks. £5.86 http://www.brickwerks.co.uk/index.php/t ... iesel.html
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶

newkid
Registered user
Posts: 58
Joined: 27 Dec 2013, 15:06
80-90 Mem No: 13142
Location: Edinburgh

Re: Possible sticking thermostat?

Post by newkid »

Ok ill buy a new thermostat and try that, the housing should be ok as it came of fine a few months back when I changed the waterpump for a brand new item but ill get one just incase.

Cheers for the help, i'll let you know how I get on.

Plasticman
Trader
Posts: 8077
Joined: 12 Oct 2005, 20:55
80-90 Mem No: 1948
Location: lincolnshire

Re: Possible sticking thermostat?

Post by Plasticman »

also hose correct at the rad ? and have you bled it the correct way
mm

newkid
Registered user
Posts: 58
Joined: 27 Dec 2013, 15:06
80-90 Mem No: 13142
Location: Edinburgh

Re: Possible sticking thermostat?

Post by newkid »

Needing a quick answer if possible.

Finally got round to changing the thermostat and the thermostat housing today, both came with new rubber o rings, but when I removed the old one I could only see one o ring, do both get used or just the one?

Thanks

Locked