Water System - I need to see a complete one

[StuM]

A couple of pics of mine - 1985 1.9DG

[croc]

What are the comments about 'auto'' cooling circuit?
The photo shows a clutch slave cylinder!

I haven't checked mine but think the hose with bolt in may be the front cabin heater.

StuM photo is of the early system by the two rubber hoses going forward on the left side.

[NicBeeee]

Could the Elephant trunks be for an old cabin heater,Eberspacher etc, they seem to be heading for the air intake. Also I am dying to know where the coolant pipe with the bolt actually ends up.

Nic

[Graham81]

There is no pipework connected to the expansion cap, that could be interesting when it gets hot.
Doesnt look like any anti freeze in the tank either.
The two flexi hoses are meant to go into the air intake, they may have perished.

[minilawz]

once again thanks to all the suggestion really helpful . Going to check the diagrams and pictures against mine engine 2moz and see if i can get some answers .

thanks

[minilawz]

i traced all the pipes 2day and found that the pipe with the bolt in goes into the 'coolant distributar' as show in the diagram. The main red pipe , bypass pipe and heater pipe and all going to the coolant distributar so the only pipe left is the auto trany cooler pipe which is the one with the bolt in thanks everyone for your help.



Also i found that the elephant trunks go into the aire intake box as shown in the picture below. does anyone know what they are for and do i need them ?

[kevtherev]

If your is not an auto then maybe its been changed from one.

Nic

yes at some point this Auto trans cooler has been disconnected