HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
Moderators: User administrators, Moderators
HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
hi all i have a t25 autosleeper 2.1 i was in it yesterday drove from nottingham to melton left it
went for a walk round then came back about an hour later it started but sounded like it was running out of fuel(had loads in)
put my foot on the throttle and would cut out left it for about half hour then started fine and drove home
did the same again just near home just cut out like it was out of fuel
can anyone help me pls
ive just orded full service kit filters etc
thanks jason
nottingham
went for a walk round then came back about an hour later it started but sounded like it was running out of fuel(had loads in)
put my foot on the throttle and would cut out left it for about half hour then started fine and drove home
did the same again just near home just cut out like it was out of fuel
can anyone help me pls
ive just orded full service kit filters etc
thanks jason
nottingham
i own a rallye golf g60 t4 caravelle camper t25 autosleeper hightop
- Ian Hulley
- Registered user
- Posts: 12661
- Joined: 11 Oct 2005, 08:08
- 80-90 Mem No: 1323
- Location: Wirksworth, Derbyshire ... or at t'mill
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
HI, welcome to the forum.
Read this from our Wiki ... https://club8090.co.uk/wiki/Pe ... ittent_2.1
Ian

Read this from our Wiki ... https://club8090.co.uk/wiki/Pe ... ittent_2.1
Ian

The Hulley's Bus
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
thanks just printed that off
fingers crossed ill get it sorted
thanks jay
fingers crossed ill get it sorted
thanks jay

i own a rallye golf g60 t4 caravelle camper t25 autosleeper hightop
- Ian Hulley
- Registered user
- Posts: 12661
- Joined: 11 Oct 2005, 08:08
- 80-90 Mem No: 1323
- Location: Wirksworth, Derbyshire ... or at t'mill
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE

Cheers, Ian.
The Hulley's Bus
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
1989 2.1DJ Trampspotter
LPG courtesy of Steve @ Gasure
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
Ian's pointed you at the right Wiki topic there
But you need to say exactly what the engine is, 2.1 MV or DJ (with or without exhaust lambda (02) sensor) and model year?
Once you have the fuel filter renewed (and have eliminated that) move on to checking earths, starting with the heavy engine and gbox ones, then the multi star-earths and bulkhead ones.
If its an MV, I'd be disconnecting the lambda sender at an early stage (tie wiring up safely out of the way)... it should run 'open loop' quite OK for diagnosis.
But do make sure you let us know the engine type and any other symptons... ve 'av vays of 'elping you fix eet

But you need to say exactly what the engine is, 2.1 MV or DJ (with or without exhaust lambda (02) sensor) and model year?
Once you have the fuel filter renewed (and have eliminated that) move on to checking earths, starting with the heavy engine and gbox ones, then the multi star-earths and bulkhead ones.
If its an MV, I'd be disconnecting the lambda sender at an early stage (tie wiring up safely out of the way)... it should run 'open loop' quite OK for diagnosis.
But do make sure you let us know the engine type and any other symptons... ve 'av vays of 'elping you fix eet

The 80-90 Tech Wikipedia Your 1st port of call

Syncro Kastenwagen / 16" Kombi Camper
Syncronaut No. 1
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
thanks guys for your help
its a dj engine and 1990
its going in today will no more later this week.
jay
its a dj engine and 1990
its going in today will no more later this week.
jay

i own a rallye golf g60 t4 caravelle camper t25 autosleeper hightop
-
- Registered user
- Posts: 4447
- Joined: 13 Jan 2010, 12:42
- 80-90 Mem No: 4418
- Location: West London - 1985 westie pop top, LHD, 1900 DF engine
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
It could be as simple as a partial fuel filter blockage. Check along your fuel line. If you find a filter with crap in it, that could be the problem. I had this problem once. I Changed the fuel filter and away we went again.
Patrick

Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
full service done fuel filter did look newish.
oil was bad,earths looked ok
so fingers crossed
oil was bad,earths looked ok
so fingers crossed
i own a rallye golf g60 t4 caravelle camper t25 autosleeper hightop
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
PRD wrote:It could be as simple as a partial fuel filter blockage. Check along your fuel line. If you find a filter with crap in it, that could be the problem. I had this problem once. I Changed the fuel filter and away we went again.Patrick
Or as complicated as an intermittent E.C.U.!!! I say this because I had exactly the same symptoms and replaced several hundred quids worth of parts during which time I was recovered about eight times and aged about ten years. Finally a nice person lent me an E.C.U and all was well. Apparently this is a very rare fault but virtually impossible to diagnose apart from substitution as all the vital signs are there - sparks, fuel, injector pulses etc.., but it just would't go! Don't get too depressed though as like I said that was a very rare fault.
Cheers
Wolfie
Well-timed silence hath more eloquence than speech.
"A quiet shy boy who took little part in games or sport"
88 High top 2.1 WBX
"A quiet shy boy who took little part in games or sport"
88 High top 2.1 WBX
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
Ken makes a good point, to be kept in the back of your mind 

The 80-90 Tech Wikipedia Your 1st port of call

Syncro Kastenwagen / 16" Kombi Camper
Syncronaut No. 1
- vag_glen
- Registered user
- Posts: 32
- Joined: 01 Oct 2006, 07:45
- 80-90 Mem No: 5774
- Location: west sussex
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
My old 2.1 dj had this issue, fitted a new afm and it was bob on after!
-
- Registered user
- Posts: 570
- Joined: 29 Jan 2007, 00:50
- 80-90 Mem No: 3784
- Location: Blackdown Hills of Devon and Somerset
- Contact:
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
Does sound a little like the AFM may be causing this. If you unplug the AFM the engine will start for a second, then die. Is this what is happening. It will only run for a second or two and will not be able to rev at all. If this is the symptom look at the plug and wiring. The plug has a wire hoop you need to press to release. Its at the back of the airbox afm.
1991 16" DJ (sold)
2006 Subaru Outback 3.0R
2010 Yamaha Ténéré
2000 KTM LC400
2006 Subaru Outback 3.0R
2010 Yamaha Ténéré
2000 KTM LC400
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
syncrosimon wrote:Does sound a little like the AFM may be causing this. If you unplug the AFM the engine will start for a second, then die. Is this what is happening. It will only run for a second or two and will not be able to rev at all. If this is the symptom look at the plug and wiring. The plug has a wire hoop you need to press to release. Its at the back of the airbox afm.
You know that was my symptom but my AFM was good. So I guess it was the part of the ECU which read or was in some way involved the AFM signal which had the intermittent fault. Not that I intend to delve into that little box of tricks though as I do have a life!
Cheers
Wolfie
Well-timed silence hath more eloquence than speech.
"A quiet shy boy who took little part in games or sport"
88 High top 2.1 WBX
"A quiet shy boy who took little part in games or sport"
88 High top 2.1 WBX
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
My van started kangarooing Monday half way up a steep hill and just about made up, also on a hill on way home. Replaced distributor cap and also rotor arm as both looking abit dicky anyway and due for renewal. Didn't help. Then checked fuel filter. Was blocked not at the filter interface but at the step down hole size in the entry end of pipe bit of the filter Blocked by a smidgin of something like cheese. 2 curled flecks of paint and a bit of hardened rubber possibly from previous cutting of petrol hose. New filter £1.75p
Re: HELP PLEASE T25 CUTTING OUT 2.1 DJ ENGINE
hi all was driving great done 80 miles just put some fuel in then after
doing that got down the road and its stoped .
it starts fine and ticks over lumpy then when i put my foot down it stops.
its starting to do my head it
does any one have a ecu i could try ?
thanks jason
doing that got down the road and its stoped .
it starts fine and ticks over lumpy then when i put my foot down it stops.
its starting to do my head it

does any one have a ecu i could try ?
thanks jason
i own a rallye golf g60 t4 caravelle camper t25 autosleeper hightop