Non-starter....2.1 DJ........Can't check wiki. FIXED

Big lumps of metals and spanners.

Moderators: User administrators, Moderators

Locked
KarlT
Registered user
Posts: 2964
Joined: 28 Nov 2005, 21:39
80-90 Mem No: 2266
Location: location, location.---Sunny South Devon
Contact:

Non-starter....2.1 DJ........Can't check wiki. FIXED

Post by KarlT »

Hi my 2.1 is playing up.

Seemed ok last week, but this week I noticed it getting harder & harder to start Felt like it was only starting on 2/3 cylinders but when reved it was fine again.

But today it was a non-starter. Looked for anything loose....no. Have checked coil...good spark. Pulled one lead off, held near engine block, mrs turned it over & it started. Kept it alive by revving reconnected lead. Left it to tick-over....went lumpy & stalled.

Any ideas?
What could breakdown in a matter of days?

As a side note, noticed when I was reving by hand, there seemed to be a whistle from round airbox, like maybe it was sucking air from somewhere. Is this sound normal?
Last edited by KarlT on 27 Jan 2009, 09:35, edited 1 time in total.

User avatar
..lee..
Registered user
Posts: 736
Joined: 04 Jun 2006, 22:13
80-90 Mem No: 4478
Location: llanelli, s wales

Re: Non-starter....2.1 DJ........Can't check wiki. :(

Post by ..lee.. »

if it idles ok for a while and gradually gets rougher it could be overfuelling. if idles ok then instantly goes to run bad would be more inclined to think spark miss fire.

if you leave it idle and stall and then pull the plugs out quickly you may find that they are wet. ie over fuelling.

i`m guessing.

lee.

User avatar
Mocki
Membership Admin
Posts: 17286
Joined: 29 Sep 2005, 09:27
80-90 Mem No: 428
Location: Mansfield Notts
Contact:

Re: Non-starter....2.1 DJ........Can't check wiki. :(

Post by Mocki »

why cant you check the wiki????
its working......



sounds like it could be a case of "manky eletrical connections" to me.Mixture not adjusting to temp change.
Steve
tel / txt O7947-137911
👀
________________

1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Auto Caravelle TS TinTop Camper 
 

big red bus
Registered user
Posts: 316
Joined: 19 Feb 2007, 16:30
80-90 Mem No: 3421
Location: west midlands (3421)

Re: Non-starter....2.1 DJ........Can't check wiki. :(

Post by big red bus »

Got exactly the same problem with my van. Have traced problem to overfueling. Have changed coolant temp sensor for genuine new vw one, no difference. changed ecu with good spare from other van, same . Swapped all sensors, air flow meter etc for ones off other van and still the same. Checked all wiring, cleaned all earths, At the present satill ot fixed so will await helpful responses as well. :D

big red bus
Registered user
Posts: 316
Joined: 19 Feb 2007, 16:30
80-90 Mem No: 3421
Location: west midlands (3421)

Re: Non-starter....2.1 DJ........Can't check wiki. :(

Post by big red bus »

Welcome to the world of owning a t3 van. Well worht the hassle though when you drive them me thinks. Coolant temp sensor is the blue one in the thermostat housing. N/s at back of engine bolted onto the head. Easier to fit , just a circlip holds it in and be quick as not to loose to much coolant. Would try thast first as there are less than £10 new genuine from vw.

KarlT
Registered user
Posts: 2964
Joined: 28 Nov 2005, 21:39
80-90 Mem No: 2266
Location: location, location.---Sunny South Devon
Contact:

Re: Non-starter....2.1 DJ........Can't check wiki. :(

Post by KarlT »

Okay tried that.....no difference.
Where next?
Have bitten the bullet & ordered a Bentley. £66 :shock:
What shall I try next while I what for it to arrive?

syncrosimon
Registered user
Posts: 570
Joined: 29 Jan 2007, 00:50
80-90 Mem No: 3784
Location: Blackdown Hills of Devon and Somerset
Contact:

Re: Non-starter....2.1 DJ........Can't check wiki. :(

Post by syncrosimon »

Karl, check your throttle position switch. If she revs up fine, but is diffiult to start that could be it. Should be able to here a tiny click when you move the throttle from closed. There is a simple off on switch attached, tells the computer to idle the engine. Follow the two wires and check for a make break circuit.

simon
1991 16" DJ (sold)
2006 Subaru Outback 3.0R
2010 Yamaha Ténéré
2000 KTM LC400

KarlT
Registered user
Posts: 2964
Joined: 28 Nov 2005, 21:39
80-90 Mem No: 2266
Location: location, location.---Sunny South Devon
Contact:

Re: Non-starter....2.1 DJ........Can't check wiki. :(

Post by KarlT »

Fixed.

Amazing what looking & poking can do!

Took off the return hose from the fuel regulator (thinking that was the fuel line :oops: to see if any fuel was getting through) & it started first turn.
Re-connected hose....non-starter.
Had spare regulator, fitted that. Started first time! :D :D :D

On closer inspection old regulator had been bent at sometime (pre-owner) . Didn't post last night because I wanted to check it would start this morning! It did, first time! :rollin

Worth a go Red Bus!

Locked