Mechanical

Moderators: User administrators, Moderators

New Topic

7642 topics

Page 78 of 153
- Jump to page:
Previous
1
…
76
77
78
79
80
…
153
Next

Topics

Replies

Views

Last post

Temp sender question

Last post by kevtherev « 28 Jun 2017, 18:31
Replies: 2
by kevtherev » 28 Jun 2017, 07:32

I have changed my old plastic thermostat housing for a metal one
In doing so I had to use a single wire sender, and modify the connector.
Would the...

2 Replies

661 Views

Last post by kevtherev
28 Jun 2017, 18:31
Starter motor

Last post by kevtherev « 28 Jun 2017, 07:13
Replies: 6
by Gibbo » 22 Jun 2017, 19:54

Advice please. I've had to revert tapping the starter motor in order to get my van going. Europarts have a REMY starter motor for £127 +VAT. Does...

6 Replies

1549 Views

Last post by kevtherev
28 Jun 2017, 07:13
Trouble bleeding clutch / replacing clutch cylinder slave

Last post by smurfbus « 27 Jun 2017, 11:46
Replies: 20
by smurfbus » 10 May 2017, 19:12
1

2
Hi,

Last weekend I spent a good few hours putting my Aidan re-built gearbox back on to my van, which all went pretty smoothly. Coming to bleed the...
20 Replies

7047 Views

Last post by smurfbus
27 Jun 2017, 11:46
Flywheel change

Last post by meggles « 27 Jun 2017, 08:20
Replies: 22
by nonny112i » 06 May 2017, 17:25
1

2
This is for my 2.1 dj engine. I've just received a flywheel off Nw_vw but wasn't there when it was purchased too be sure it's right. I've got some...
22 Replies

5152 Views

Last post by meggles
27 Jun 2017, 08:20
Pistons.

Last post by kevtherev « 27 Jun 2017, 21:34
Replies: 1
by aerovolito » 26 Jun 2017, 17:56

I have to do some work on my AAZ. I know Mahle pistons are the standard but what others are quality for less money?

1 Replies

1783 Views

Last post by kevtherev
27 Jun 2017, 21:34
How HOT does your PAS pump/rack get?

Last post by what2do « 26 Jun 2017, 12:36
Replies: 7
by akw » 25 Jun 2017, 19:31

Hi,

I just replaced pretty much the entire power steering system (pump, rack, lines etc) but it's running pretty hot, especially at motorway speeds....

7 Replies

1469 Views

Last post by what2do
26 Jun 2017, 12:36
What to do about my gearbox?

Last post by bigbadbob76 « 26 Jun 2017, 09:14
Replies: 24
by bigbadbob76 » 04 May 2017, 14:14
1

2
So.
My gearbox grates when selecting 3rd gear, both shifting up and down.
All other gears select quietly.
If I shift below 30mph and double declutch...
24 Replies

4424 Views

Last post by bigbadbob76
26 Jun 2017, 09:14
1.9DG Petrol Water Boxer - Mystery Engine Part

Last post by QuickBrownFox « 25 Jun 2017, 21:43
Replies: 9
by QuickBrownFox » 23 Jun 2017, 17:00

170623_174730_COLLAGE-1.jpg Hello,

First post, please be forgiving... I tried to be specific in my subject, but specifics are one thing I'm short...

9 Replies

2576 Views

Last post by QuickBrownFox
25 Jun 2017, 21:43
Steering Fluid for T25 California 1.6TD

Last post by California Dreamin « 25 Jun 2017, 18:53
Replies: 2
by wbmkk » 24 Jun 2017, 16:28

Hi

Just noticed today that the steering fluid is approaching the minimum level.

Which steering fluid is needed please.

I have a 1989 turbo diesel...

2 Replies

1169 Views

Last post by California Dreamin
25 Jun 2017, 18:53
Oil Drip

Last post by Mark S « 25 Jun 2017, 17:48

by Mark S » 25 Jun 2017, 17:48

AAZ (1.9 TD) using JX manifolds and K14 turbo.

Bus went in to garage for some work recently. Got a phone call about a 'major problem' they had found...

0 Replies

1897 Views

Last post by Mark S
25 Jun 2017, 17:48
Westy started jumping out of gear

Last post by Mark S « 25 Jun 2017, 17:32
Replies: 2
by Mark S » 29 May 2017, 18:42

Into neutral from 4th and 5th, while under acceleration at mid-revs. It did it a few times over the weekend and had never done it before in the 15...

2 Replies

895 Views

Last post by Mark S
25 Jun 2017, 17:32
Handbrake balance thing!

Last post by rockthebus « 25 Jun 2017, 16:55
Replies: 9
by rockthebus » 21 Jun 2017, 08:48

Stupid me removed the handbrake balance piece (where the 2 cables become 1) without noticing it's orientation.

My Westy is lhd so that will make a...

9 Replies

1988 Views

Last post by rockthebus
25 Jun 2017, 16:55
Replacement Fuel Lines Question

Last post by bigherb « 25 Jun 2017, 16:45
Replies: 7
by chewbacca » 10 Jun 2017, 21:27

Hi guys.
I'm wanting to swap out fuel lines.
Is there any reason not to just replace from tank to engine with single lengths of hose?
(Excluding the...

7 Replies

1670 Views

Last post by bigherb
25 Jun 2017, 16:45
Original DG Engine life?

Last post by scottbott « 25 Jun 2017, 08:02
Replies: 5
by AngeloEvs » 23 Jun 2017, 11:48

I am looking to buy a Water cooled 1.9DG and wondering what other members consider about T25s that still have the original WC DG engine fitted....

5 Replies

2023 Views

Last post by scottbott
25 Jun 2017, 08:02
Electric Fuel Pump Noise? (DG)

Last post by CovKid « 24 Jun 2017, 06:59
Replies: 17
by richlaz » 20 Jun 2017, 16:08
1

2
Hi all,

My van (1.9DG) has recently had an electric fuel pump fitted by my local garage... (my old original one was very weak, and wouldn't draw up...
17 Replies

5354 Views

Last post by CovKid
24 Jun 2017, 06:59
Over Heating Issue - 1.6 TD (86 Westy Joker)

Last post by Oldiebut goodie « 23 Jun 2017, 22:27
Replies: 14
by budda666 » 17 Jun 2017, 11:25

Long time since I've been round these parts...Long story short as we've just returned home to leave the van for the weekend to grab the car and tent...

14 Replies

3702 Views

Last post by Oldiebut goodie
23 Jun 2017, 22:27
1.7 KY TD

Last post by The Hairy Camper « 23 Jun 2017, 19:24
Replies: 4
by The Hairy Camper » 23 Jun 2017, 18:00

Anyone here heard of adding a turbo to 1.7 KY engine?

I've just been told by a mechanic that it's quite a popular modification for these engines?

I...

4 Replies

980 Views

Last post by The Hairy Camper
23 Jun 2017, 19:24
Fuel Filter advice.

Last post by itchyfeet « 23 Jun 2017, 15:23
Replies: 3
by ROBSEA » 22 Jun 2017, 15:17

After spluttering my way home , I noticed my fuel filter black and severely clogged. Have replaced with the exact same HENGST filter that came with...

3 Replies

1351 Views

Last post by itchyfeet
23 Jun 2017, 15:23
Idle speed changes when the engine is hot

Last post by Bubble Meister « 23 Jun 2017, 15:00
Replies: 1
by Bubble Meister » 21 Jun 2017, 17:51

Whenever I have had a good run the idle speed changes! Generally it will have increased to around 1000rpm. Rarely, it will drop to around 700rpm and...

1 Replies

568 Views

Last post by Bubble Meister
23 Jun 2017, 15:00
Won't idle then dies after hot engine restart

Last post by flora « 23 Jun 2017, 14:49
Replies: 8
by flora » 18 Jun 2017, 14:11

I have a 1987 automatic with reconditioned 1.9 DG water-cooled petrol engine that from cold starts and runs well with no problems. However, this (v...

8 Replies

3324 Views

Last post by flora
23 Jun 2017, 14:49
Hot start 'no crank' 1.9 dg

Last post by Zcat7 « 23 Jun 2017, 01:05
Replies: 10
by sonnyhowell » 04 Jun 2017, 14:09

Hey guys

I am posting this as I don't seem to be getting anywhere every time i search. Maybe I'm not using the right terms.

I'm having a hot start...

10 Replies

4100 Views

Last post by Zcat7
23 Jun 2017, 01:05
2.0L CU air cooled - intermittent backfire

Last post by Sir Brixalot « 22 Jun 2017, 18:50
Replies: 11
by neil3965 » 07 Apr 2015, 11:49

Hi all - hoping for some insight.

Problem is random, loud backfire (anything from 2 to 150 miles in between each event) - just a single very loud...

11 Replies

9376 Views

Last post by Sir Brixalot
22 Jun 2017, 18:50
Checking CV Joints for wear

Last post by bene « 22 Jun 2017, 09:02

by bene » 22 Jun 2017, 09:02

Hello!
So, I have some second hand Porsche CVs to go into the syncro but i want to check them for wear...
Does anybody have any pointers of what to...

0 Replies

1232 Views

Last post by bene
22 Jun 2017, 09:02
Running rich

Last post by gwynny « 22 Jun 2017, 06:51
Replies: 1
by Budgie7 » 18 Jun 2017, 09:16

Van started fine yesterday morning, but after running for 2 or 3 minutes started to stutter , I took her out and normal driving didn't seem to be a...

1 Replies

879 Views

Last post by gwynny
22 Jun 2017, 06:51
Mac Sport/L&T Garage Ellesmere Port

Last post by The Hairy Camper « 21 Jun 2017, 23:06

by The Hairy Camper » 21 Jun 2017, 23:06

Hi people, i hope this is post is in the right place? Can a mod please move if not.

I was wondering if any users have used Mac Sport/L&T Garage in...

0 Replies

1326 Views

Last post by The Hairy Camper
21 Jun 2017, 23:06
Start/tickover problem

Last post by Hedges « 21 Jun 2017, 19:49
Replies: 17
by Hedges » 13 Jun 2017, 21:49
1

2
1987 1.9 petrol DG Pierberg carb
Been off road for a while whilst sorting getting ready for mot but was running ok. Needed new petrol tank, so that's...
17 Replies

4066 Views

Last post by Hedges
21 Jun 2017, 19:49
Same anti roll bar snapped twice in 4 years

Last post by Oldiebut goodie « 21 Jun 2017, 19:11
Replies: 1
by badgerfax » 21 Jun 2017, 18:58

Soon after getting this van around 4 years ago It suffered a snapped anti roll bar drop link on the off side, This followed a long hot journey from...

1 Replies

842 Views

Last post by Oldiebut goodie
21 Jun 2017, 19:11
Cold Start Cable Routing?

Last post by Scottish Motorsport « 21 Jun 2017, 17:45

by Scottish Motorsport » 21 Jun 2017, 17:45

Hi,
Can someone please tell me how you route the cold start cable i bought my van with no cold start cable fitted. i have all the parts required to...

0 Replies

1214 Views

Last post by Scottish Motorsport
21 Jun 2017, 17:45
Solex 34 PDSIT fuel overflow

Last post by melvin « 21 Jun 2017, 09:46
Replies: 5
by melvin » 21 Jun 2017, 07:31

Hi all,
Does anyone know what this pipe is and why fuel might be pissing out of it on a hot engine?
Long story short, I went for an hours drive,...

5 Replies

1966 Views

Last post by melvin
21 Jun 2017, 09:46
Gearbox spanner

Last post by Titus A Duxass « 20 Jun 2017, 13:02
Replies: 1
by wasp229 » 20 Jun 2017, 12:43

3h gearbox playing up. Friend said he could dismantle and check for wear. Now tells me he needs a special huge serrated spanner. Any ideas of...

1 Replies

715 Views

Last post by Titus A Duxass
20 Jun 2017, 13:02
Jx 1.6td misfire

Last post by Weem Machine « 19 Jun 2017, 22:40
Replies: 11
by pierce » 17 Jun 2017, 18:55

Hi,

I wondered if anyone has any thoughts on an issue I am having.

A couple of weeks back, my low pressure oil light was coming on for a couple of...

11 Replies

2953 Views

Last post by Weem Machine
19 Jun 2017, 22:40
Carb info please

Last post by Wedgiebaby « 19 Jun 2017, 20:46
Replies: 2
by Wedgiebaby » 19 Jun 2017, 10:25

Hi,
I havn't been here for a while, so apologies for making my first post for ages, a plea for help!
Had to have the RAC man out yesterday as Wedgie...

2 Replies

865 Views

Last post by Wedgiebaby
19 Jun 2017, 20:46
JX to AAZ conversion Pre-empting crank bolt/nose problems

Last post by wolfbus.uk « 19 Jun 2017, 10:50

by wolfbus.uk » 19 Jun 2017, 10:50

After many months of searching i've fortunately found a 58.000 mile FSH running AAZ bought from an old boy in the next village.

I've been driving...

0 Replies

1308 Views

Last post by wolfbus.uk
19 Jun 2017, 10:50
Rad fan cooling

Last post by vwaddict « 03 Aug 2017, 19:04
Replies: 7
by vwaddict » 17 Jun 2017, 23:49

I have a water cooled t25 which was a jx but now has a AGG conversion fitted, my temperature gauge allways sits just over 3/4 even when the jx was...

7 Replies

3565 Views

Last post by vwaddict
03 Aug 2017, 19:04
1.6 TD JX fuel issue!

Last post by pierce « 17 Jun 2017, 21:36
Replies: 5
by garrybaldy007 » 16 Jun 2017, 20:01

Hi,

I've been on this site for a while now and got some good tips which I really appreciate, however I now have a fault that I'm struggling with. I...

5 Replies

1630 Views

Last post by pierce
17 Jun 2017, 21:36
Oil leak from sensor 16TDjx

Last post by nevill3 « 17 Jun 2017, 20:35
Replies: 2
by jacko1967 » 14 Jun 2017, 19:19

Hi ive got an oil leak today only just noticed it on drive way had a look in engine bay and it seams to be coming from the sensor on the oil filter...

2 Replies

841 Views

Last post by nevill3
17 Jun 2017, 20:35
Vw part number for temp sensor o ring please

Last post by chewbacca « 17 Jun 2017, 11:58
Replies: 2
by chewbacca » 17 Jun 2017, 11:07

Hi guys.
I have the plastic thermostat housing with the clip in sensors.
The sensor nearest the front of the bus appears to be leaking, so I'm hoping...

2 Replies

796 Views

Last post by chewbacca
17 Jun 2017, 11:58
anti roll bar hitting steering ????

Last post by Domino « 17 Jun 2017, 09:23
Replies: 4
by Domino » 16 Jun 2017, 19:54

after changing a few items on the van in search of a knocking from the front end ,, like all the anti roll bar bushes and ball joints iv now noticed...

4 Replies

1712 Views

Last post by Domino
17 Jun 2017, 09:23
T25 Manchester garage needed

Last post by jrt « 16 Jun 2017, 20:21
Replies: 3
by Cemi42 » 14 Jun 2017, 21:37

Hi. Looking to find a local garage recommended that will do servicing +. can anyone recommend one around south Manchester?
Thanks

3 Replies

2479 Views

Last post by jrt
16 Jun 2017, 20:21
BOD

Last post by R0B « 15 Jun 2017, 18:13
Replies: 2
by R0B » 15 Jun 2017, 17:41

Did an oil 15w 40 &filter change last week.Driving up the motorway 60/70 MPH this afternoon the oil light and buzzer came on.Managed to pull...

2 Replies

664 Views

Last post by R0B
15 Jun 2017, 18:13
Chrome bumpers

Last post by CovKid « 15 Jun 2017, 12:14
Replies: 9
by sonnyhowell » 07 Jun 2017, 23:32

Has anyone got any experience/views on the repro chrome bumpers. Looking to get a set (want the more expensive thicker chrome) not the sunny climate...

9 Replies

1806 Views

Last post by CovKid
15 Jun 2017, 12:14
Eurocarparts wheel cyl ref

Last post by rockthebus « 14 Jun 2017, 22:07
Replies: 4
by rockthebus » 14 Jun 2017, 17:05

Could someone pm me the reg of a 1990 2.1. Or the part number for the nearside wheel cylinder on eurocarparts as my reg isn't recognised on their...

4 Replies

2935 Views

Last post by rockthebus
14 Jun 2017, 22:07
another oil leak

Last post by glennhod « 14 Jun 2017, 20:07
Replies: 5
by glennhod » 13 Jun 2017, 11:45

can some one help please ive had flywheel seal done oil cooler seals done push rod tubes done and now ive found this leak seams to be all over...

5 Replies

1315 Views

Last post by glennhod
14 Jun 2017, 20:07
Won't idle after 10 minutes at motorway speeds

Last post by kevtherev « 14 Jun 2017, 19:14
Replies: 8
by Inchworm » 02 Jun 2017, 17:20

I have a 1986 T25 with a 1.9 DG engine.
Several trips ago it stated stalling after exiting the motorway. It would start right up again but I couldn't...

8 Replies

1685 Views

Last post by kevtherev
14 Jun 2017, 19:14
Tiny Oil leak

Last post by hightop ratty « 14 Jun 2017, 16:47
Replies: 13
by crazyhorse » 09 Jun 2017, 09:14

Hi all,

I seem to have slight oil leak. See picture.

Level is fine, and it never leaves a drop on the road, not that Ive noticed.

Will it be ok...

13 Replies

4886 Views

Last post by hightop ratty
14 Jun 2017, 16:47
1.6 td oil level

Last post by quattrodave « 14 Jun 2017, 06:11
Replies: 4
by quattrodave » 11 Jun 2017, 19:17

I've had to renew the Turbo to sump oil return pipe today so had to drain the oil 1st. After having dipstick and oil level problems previously I...

4 Replies

2371 Views

Last post by quattrodave
14 Jun 2017, 06:11
T25 ride height

Last post by nesty « 13 Jun 2017, 23:33
Replies: 5
by coolrunnings » 12 Jun 2017, 15:53

Was convinced my T25 DOKA was lowered, I don't know by how much, but it looks lower and handles better than my old camper. Now comes the problem, one...

5 Replies

2459 Views

Last post by nesty
13 Jun 2017, 23:33
T25 84 Side elevating roof Strut replacement

Last post by LeeCarey « 09 Apr 2023, 14:41
Replies: 4
by 69gp225 » 13 Jun 2017, 20:11

Hello,

Would like to replace the 4 roof struts on my 84 side elevating Devon roof.
What's is the procedure to achieve this?

Would I be right in...

4 Replies

3385 Views

Last post by LeeCarey
09 Apr 2023, 14:41
Injection fuel pump

Last post by slowcoach « 13 Jun 2017, 15:16
Replies: 1
by slowcoach » 13 Jun 2017, 10:42

Hi folks,
I've had another thread in the modified engine forum, but now it's narrowed down to fuel issues a need a quick answer, as still hobbling...

1 Replies

613 Views

Last post by slowcoach
13 Jun 2017, 15:16
handbrake help

Last post by Titus A Duxass « 13 Jun 2017, 10:57
Replies: 3
by ermie571 » 13 Jun 2017, 08:58

ok. I have two vans.
1990 caravelle hightop. Handbrake is fine. Will hold on a hill.
1984 panel conversion. Handbrake passes mot..but I cannot pull...

3 Replies

892 Views

Last post by Titus A Duxass
13 Jun 2017, 10:57

New Topic

7642 topics

Page 78 of 153
- Jump to page:
Previous
1
…
76
77
78
79
80
…
153
Next

Return to Board Index

Forum permissions

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum