Search found 9 matches

by munkeyh
03 Jul 2017, 13:14
Forum: Mechanical
Topic: 2.1dj Inj Auto - rough running after re-assembly
Replies: 9
Views: 1868

Re: 2.1dj Inj Auto - rough running after re-assembly

Ha ha, yes I meant bar not psi - oops
by munkeyh
03 Jul 2017, 11:45
Forum: Mechanical
Topic: 2.1dj Inj Auto - rough running after re-assembly
Replies: 9
Views: 1868

Re: 2.1dj Inj Auto - rough running after re-assembly

Cheers folks, appreciate all the advice. I'll start the hunt for air leaks although it might have to wait for the weekend again. Interestingly I drove it around it around the block last night and when I pulled back up and left it at idle my fuel pressure was around 1.8psi (which has gone down from w...
by munkeyh
02 Jul 2017, 18:16
Forum: Mechanical
Topic: 2.1dj Inj Auto - rough running after re-assembly
Replies: 9
Views: 1868

Re: 2.1dj Inj Auto - rough running after re-assembly

Hiya, and thanks guys. I did disconnect the vacuum pipes and blocked them whilst I set the timing - wasn't sure if that was totally correct? I've seen differing opinions? I'll recheck the timing again. I've not had several hours of running out of mine yet, I didn't want to keep running it as I was w...
by munkeyh
02 Jul 2017, 15:44
Forum: Mechanical
Topic: 2.1dj Inj Auto - rough running after re-assembly
Replies: 9
Views: 1868

2.1dj Inj Auto - rough running after re-assembly

Hi folks, I'm looking for some advice or someone local to Loughborough to take a look at my van please. Its the 2.1 fuel injected automatic. Having put the engine back together, its running a little lumpy, from the exhaust note it almost sounds a bit poppy, like its not running cleanly on all cylind...
by munkeyh
26 Mar 2017, 07:33
Forum: Mechanical
Topic: 2.1dj crankshaft end float advice please
Replies: 6
Views: 1497

Re: 2.1dj crankshaft end float advice please

Great idea, but I think I'll just take out the existing engine though, it will encourage me to get it done faster :D I can't seem to add photos, might need to talk to admin. I'm going to hold onto the flywheel for a little while incase I do go manual at any point. But if I do go crazy and start to h...
by munkeyh
24 Mar 2017, 20:19
Forum: Mechanical
Topic: 2.1dj crankshaft end float advice please
Replies: 6
Views: 1497

Re: 2.1dj crankshaft end float advice please

Thanks for confirming, I'm following the Haynes but then I had a little think about what I was actually measuring. I'd hate to get this far and then make the crank too tight or too loose. It's the availability of advice from people like yourself that makes it possible for people to have a go, so tha...
by munkeyh
24 Mar 2017, 19:10
Forum: Mechanical
Topic: 2.1dj crankshaft end float advice please
Replies: 6
Views: 1497

2.1dj crankshaft end float advice please

I'm rebuilding a 2.1dj (my first rebuild) and have measured the crank shaft end float, with the flywheel on as the Haynes suggests. So I know what shims to buy. However my rebuild engine came from a van with a manual gearbox, hence the flywheel, but it will replace the engine currently in my van and...
by munkeyh
06 Mar 2017, 14:52
Forum: Mechanical
Topic: What Crankcase sealant - 2.1dj rebuild
Replies: 2
Views: 726

Re: What Crankcase sealant - 2.1dj rebuild

Much appreciated, I like the price too.

Thanks !!!!
by munkeyh
06 Mar 2017, 14:10
Forum: Mechanical
Topic: What Crankcase sealant - 2.1dj rebuild
Replies: 2
Views: 726

What Crankcase sealant - 2.1dj rebuild

Hi folks, I'm doing my first engine rebuild, its a 2.1 DJ. Just wondering what folks use to seal the two crankcase halves together? I'm not planning to make a habit of this, so although I want to make sure its done properly I'm not looking to buy a bucket of the stuff.

Much appreciated,
Mark