Club 80-90 Forums

Went to clean windscreen on way to Stop Over and no screen wash. Assumed tank empty so went to top it up last night to find it nicely full with lovely screen wash therefore something electrical has gone wrong.

Windscreen wipers working fine but no water when I pull the wiper arm. Could be a pump or could be a fuse I guess.

Any advice on how to fix it? I heard the pump is in the screen wash tank but not 100% on that.

Cheers in advance.
Sarah

i fitted a new pump to mine, is attached to the washer bottle, basically undo the bolts from under passenger footwell which hold the washer bottle in.

drop out of van then swap for new pump cant remember the model but it is written on it.

good luck!

cool, sounds straight forward enuff!

Thanks
Sarah

you can get the pumps from halfwits

Schweet

Ta!

Mine stopped due to crap in the water tank, spun the pump by hane and been ok since
mike

Give the puma got tap see if it springs to life first often jumps them back into life!

jamesc76 wrote:Give the puma got tap

Pardon? Or as Little T would say "whatty whot?"

LOL.

Ta tho

oooops give the pump a tap often works then but not every time!

Lol lol lol. I've heard of a tiger in your tank, thought maybe I was missing some secret squirrel t25 info there involving a puma!!!

Cheers, I'll give it a go.
S

Worth checking the pipes from the pump to the nossles as any crap blocks the nossles.

Mark

could well be the switch on the stalk......
get a alternative power supply down to the pump, a known 12v and see is the pump works before you spend any money,
or a bulb with a couple of wires and connect to the pump wires and see if power is getting there....they commonly fail due to the switch being dirty ......

Had the same problem on mine.
Dropped tank onto a large piece of timber so every thing was still connected, disconnected the cable to th pump & put a 12v supply onto the pump using a starter pack & some small leads. Pump was good, so checked fuses & relays, all good too.
Removed plastic covers from steering column & found switch contact to be dirty, cleaned dirt off with some fine grit wet n dry, hey presto, clean windscreen!
Hope this helps.

Rob

any ideas on who sells the pumps, checked mine and it is missing.

Jocko,
I think Just Kampers sell them, but may need to be modified & quality may not be great. Also try Brickwerks & GSF.

Bob