Page 1 of 1

1.6td diesel pump, wont draw diesel

Posted: 26 Jul 2008, 21:44
by 1990panelvan
almost finished my passat 1.6td into t25. now went to bleed the diesel pump (jx pump) and cant get the pump to draw any diesel up. now is this a common problem with the pump? what would break on the pump to make it not suck. and can it be repaired? any ideas?
Tony

Posted: 26 Jul 2008, 21:56
by dugcati
I found with my last van that getting the pump to pump was a complete pig..

I ended up taking off the fuel in union and then syringing diesel into the pump until full. After that is was a FULLY charged battery and a fair bit of engine cranking and presto - the only other thing I did was to crack off the fuel line on one of the injectors as it was 'bouncing' due to an airlock that wouldn't go - in the end it turned out that that injector was a crappy one so I replaced it :wink:

Posted: 27 Jul 2008, 07:22
by ringo
Take off the return fuel line at the pump - this makes priming the system a lot easier. However, when the engine does fire up - be sure to be there so you can reconnect it as diesel will go everywhere....

Ringo

PS. Out of interest, why didnt you leave the 1.6td pump on?

Posted: 27 Jul 2008, 08:48
by Westy.Club.Joker
Fill the pump like Dug says, also make sure the filter is full and try to get the pipe from the filter to th pump full as well. I had the same probs. Took me a hour to get it to draw the fuel up.

Posted: 27 Jul 2008, 08:52
by 1990panelvan
thanks for that will give it a go! wish i did use the passat pump now. but thought that it would hit the top of the engine lid

Posted: 27 Jul 2008, 20:30
by ringo
1990panelvan wrote:thanks for that will give it a go! wish i did use the passat pump now. but thought that it would hit the top of the engine lid

It will do - but a simple mod can solve that. You can buy the bits to do the mod from brickworks....

I would have thought the passat one was better - but i dont know.

Any thoughts Westy?

Ringo