Page 1 of 1
JX failed MOT on high emissions??
Posted: 23 Feb 2015, 13:12
by Holydiver
the van just fail the MOT on emissions (JX diesel) does anyone have any idea’s on over coming this? Can’t moan as it’s the first failure in 5 years!
Going to Halfords lunch time to get some red-X to run through it, plus a few trips up and down the motorway as it’s only done short journeys recently??
New injector fitted 2x years ago.
Re: JX failed MOT on high emissions??
Posted: 23 Feb 2015, 15:13
by MGP
First thing to check is the air filter is clean and the snorkel pipework is clear, I have seen the pioework disintigrate internally and partially block itself.
Next up is a new fuel filter and that there are no air bubbles in the fuel lines.
After those its timing and compression checks.
Re: JX failed MOT on high emissions??
Posted: 23 Feb 2015, 17:23
by Holydiver
1. Been running a K&N filter for a couple of years, is it worth fitting a standard element just for MOT retest??
2. didn't change it last year as only did 3K on it, as I have a new one in the shed I will fit it anyway
3. I did the cam belt in April and the timing was correct at that point?
Going to drive it to work this week via the motorway and retest Friday, guess if it fails then I'll need to look deeper!!
Re: JX failed MOT on high emissions??
Posted: 23 Feb 2015, 19:07
by MGP
Give the k&n a good clean and go from there.
If it stands about alot then there is a good chance that there could be water in the fuel tank from condensation which would collect in the filter so worth changing that.
Is your fuel filter the one with the plastic valve in the top? If so it could be worth changing as that can cause air to enter the pump which will play havoc with the advance curve and put the emissions out.
Re: JX failed MOT on high emissions??
Posted: 23 Feb 2015, 19:27
by Holydiver
Cheers
Yes it does have the white valve and again i have a couple of new one in the shed!! Don't ask?
Re: JX failed MOT on high emissions??
Posted: 23 Feb 2015, 21:10
by colinthefox
Fill it up with premium diesel, and take it for a real good long thrash immediately before the test.
Re: JX failed MOT on high emissions??
Posted: 23 Feb 2015, 21:20
by marlinowner
You want to get the oil really hot to get rid of volatiles that go into the crankcase breather. Or change the oil, that lowered the emissions on my DG to pass the MOT.
Re: JX failed MOT on high emissions??
Posted: 27 Feb 2015, 21:14
by Holydiver
colinthefox wrote:Fill it up with premium diesel, and take it for a real good long thrash immediately before the test.
Also changed the fuel filter, yep that did the trick
Re: JX failed MOT on high emissions??
Posted: 27 Feb 2015, 21:47
by colinthefox
Pleased for you.
My Vol-vo 850 diesel scores 6 or more (!) on smoke if I don't thrash it first, 1.75 if I do.
It has done 320K miles though.