Club 80-90 Forums

Hello all, wondering if you could advise on the following.

When driving my van i'm noticing a strange sound when at the higher end of the rev range, it sounds like its coming from the turbo. The noise sounds like air being released from some where. But it doesn't sound like healthy air release, it sounds tinny and rattly, hard to explain with words.

When this noise occurs the van loses a little power, which makes me think its the turbo.

It happens in all gears at high revs, when in 5th gear the noise will occur for a second or two with a little power loss, the noise then disappears for a second or two van surges forwards a little, the noise occurs again for a second or two van loses power so on and so forth.

I've tried revving the engine by hand from the engine bay but don't hear the noise.

Any ideas what it could be.

Engine has just been rebuilt, but the turbo hasn't.

Any advice greatly appreciated.

take the inlet pipe off the turbo and see if there is any movement on the cross shaft. might be failing under heavy load.

Hi Rob, try sticking a wine cork in the blow off valve

^^^WHS

Oooooh anything else you can fix with a wine cork? I don't have a turbo but any excuse to crack a bottle eh???

It has to be a "Rioja" wine cork!!

I had something similar. It only happened at high rpm under a heavy load and turned out to be the inlet duct. It would collapse, making a loud 'wheezing' sound and cause loss of power. Once the load was off it would go back to normal.

Appolgies for the late reply folks, thanks for your advice, i'm gonna give it a look at later this week, did you replace the duct causing your problem? Now, wheres them old wine bottles!