Page 2 of 2
Oil Leak
Posted: 10 Aug 2007, 13:00
by DJZ
Check your dipstick as well, I have 16 diesel and my dipstick seal had gone so the oil was blowing out of there onto the exhaust causing lots of mess on back. New dipstick done the job.
Posted: 13 Aug 2007, 14:23
by AquaMan + kids
Hi all,
Well decided to have a go at the gasket today.
Got the rocker cover off and found a very tired looking gasket, but it also looked like there was previously some sort of sealant.
So next question is do I apply sealant?
And is there any particular type of sealant I should use?
Regards
Aquaman
Re: Oil Leak
Posted: 13 Aug 2007, 15:52
by AquaMan + kids
DJZ wrote:Check your dipstick as well, I have 16 diesel and my dipstick seal had gone so the oil was blowing out of there onto the exhaust causing lots of mess on back. New dipstick done the job.
I think there are signs of oil coming out of the dipstick.
Had a look on JustKampers for a new one, couldn't see one that was specific to my engine.
DJZ -where did you get yours from?
Aquaman
dipsticks
Posted: 13 Aug 2007, 17:59
by tonytone
go to any VW van centre.Its either an on the self or order part. I got a new one for my diesel for about 6-8 quid.
Posted: 13 Aug 2007, 18:52
by AquaMan + kids
AquaMan + kids wrote:Hi all,
Well decided to have a go at the gasket today.
Got the rocker cover off and found a very tired looking gasket, but it also looked like there was previously some sort of sealant.
So next question is do I apply sealant?
And is there any particular type of sealant I should use?
Just in case the above question was missed, I have reposted it.
Basically do I need sealant for the rocker cover gasket?
Aquaman
Dipstick
Posted: 13 Aug 2007, 23:29
by DJZ
As Tonytone said any VW commercial dealer will have them.
Posted: 14 Aug 2007, 09:53
by AquaMan + kids
So what we're saying here, just to get things clear, and sorry to sound like a true novice is:
That I can get sealant from a van centre and I can get a new dipstick.
Aquaman
Posted: 15 Aug 2007, 19:31
by AquaMan + kids
hi
my other half Aquaman has tried to do this job but has come in tonight saying the problem is worse now than ever
he replaced the gasket but now oil is leaking more than it ever was but from a different place.
He has tried to remove the cover to start all over again but one of the bolts has now sheared off.......
any tips anyone?
ahahg we should have been camping this week ........
thanks again
helen
Posted: 15 Aug 2007, 20:50
by big red bus
Take the cam cover off again and make sure the gasket is fitted correctly. As for the broken bolt. Is there any thread sticking up from the head or has it broken off flush with the top of the head. If broken off flush then it will be a whole lot more difficult to get out than if you have a bit to try and grab. If there is thread then get some mole grips or pliers and try and unscrew. If it's leaking worse than before you can only go back and look at what has been messed with. Where or what area is it now leaking from? Good luck.