Possible air lock in fuel line/ pump T25 1998 (diesel)
Moderators: User administrators, Moderators
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
Possible air lock in fuel line/ pump T25 1998 (diesel)
Hi all,
Lost power yesterday, not dead loss.
More like slowly lost power, fuel was low.
Anyway, it wouldn’t start.
Last night I topped up the fuel, this morning it ran for 1 min, spluttered a bit and eventually cut out.
Noted the fuel lines had some air in them, what’s the best way of clearing this Air?
[youtube]https://youtube.com/shorts/cjbjydLOEQ8? ... Rd6HX8kHVE[/youtube]
Lost power yesterday, not dead loss.
More like slowly lost power, fuel was low.
Anyway, it wouldn’t start.
Last night I topped up the fuel, this morning it ran for 1 min, spluttered a bit and eventually cut out.
Noted the fuel lines had some air in them, what’s the best way of clearing this Air?
[youtube]https://youtube.com/shorts/cjbjydLOEQ8? ... Rd6HX8kHVE[/youtube]
T25 1989
- Oldiebut goodie
- Registered user
- Posts: 7481
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Blocked fuel filter? I had gunk blocking the filter and the banjo connector from the tank. Same symptoms, gradual loss of power then could only crawl along at 5mph.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
So pull it off, clean it out and re-install?
Cheers
Cheers
T25 1989
-
- Registered user
- Posts: 2184
- Joined: 10 Aug 2019, 23:30
- 80-90 Mem No: 17004
- Location: Coventry
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
take it off and put a new filter on you mean, loosen one of the injector hoses and crank the engine that should bleed the air out then tighten it up when you get fuel coming through it.
1985 LeisureDrive 2.1DJ 5 Speed syncro conversion project.
1979 LT 2.0 CH Westy project
1986 LT 2.4 D24T Reimo
1979 LT 2.0 CH Westy project
1986 LT 2.4 D24T Reimo
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Daleck cap is known to give problems. You could try to establish if it is working by blowing through it( so called quack test ) or better still buy a new quality replacement ( Blau from brickwerks should be good) ,easy fix if this is the problem.
Another likely reason for your coolant problems would be exhaust gasses getting past the head gasket,much more involved to repair!
Another likely reason for your coolant problems would be exhaust gasses getting past the head gasket,much more involved to repair!
- Oldiebut goodie
- Registered user
- Posts: 7481
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Errrrr....... wrong thread methinks! ( or diesels run on water nowCecil wrote: ↑11 Aug 2024, 07:48 Daleck cap is known to give problems. You could try to establish if it is working by blowing through it( so called quack test ) or better still buy a new quality replacement ( Blau from brickwerks should be good) ,easy fix if this is the problem.
Another likely reason for your coolant problems would be exhaust gasses getting past the head gasket,much more involved to repair!

1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Woops the daisy.
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Ok, got a new fuel filter, but I ended up shorting something while installing it, I think it was something on the starter/ glow plug circuits.
So another issue to deal with.
My glow plug light does not light up on the dash, where’s a good start? Did I blow the relay for the glow plugs? (Relay 60, in rear junction box) any easy checks?
So another issue to deal with.
My glow plug light does not light up on the dash, where’s a good start? Did I blow the relay for the glow plugs? (Relay 60, in rear junction box) any easy checks?
T25 1989
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Also, Do I prime the new fuel filter in some way?
T25 1989
- Oldiebut goodie
- Registered user
- Posts: 7481
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Have you checked the banjo connector for crud?
I always fill a filter, oil or fuel, before fitting.
I always fill a filter, oil or fuel, before fitting.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Would this be the same relay (I’m in Ireland, so looking for a local online store)
No Bricks and Mortar stores seem to carry many relays.
https://www.auto-doc.ie/jp-group/8178181
No Bricks and Mortar stores seem to carry many relays.
https://www.auto-doc.ie/jp-group/8178181
T25 1989
-
- Registered user
- Posts: 24
- Joined: 09 Jul 2024, 18:26
- 80-90 Mem No: 0
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
Yip, checked all the lines and connectors to make sure they are clear 
T25 1989
-
- Registered user
- Posts: 328
- Joined: 20 Dec 2013, 12:05
- 80-90 Mem No: 11015
- Location: Ireland
Re: Possible air lock in fuel line/ pump T25 1998 (diesel)
If your in Ireland there is vwspares.ie, air-cooled-parts.com or vantopia.ie . I am in Ireland as well and I use those three of I need parts and haven't been let down yet by them and the owners all seem nice and very clued in if you contact them.
1Y 1990 5 speed 1.9D