Diesel Injector Querie UPDATE

for questions and answers about alternative power transplants on the T25, GTi, Porsche,Subaru etc, this is the place. You must register to post but anyone can read.

Moderators: User administrators, Moderators

Post Reply
sauce1001
Registered user
Posts: 123
Joined: 12 Aug 2006, 03:24
80-90 Mem No: 2816
Location: Leicestershire

Diesel Injector Querie UPDATE

Post by sauce1001 »

Hi all, my van's running a 1.9TDI conversion, engine code ALH.

It's very smokey on start up, no smoke when idling but lots of smoke when revved. I've noticed an issue round the injector on the attached picture.  There was a rough looking loose rubber cap over that nipple, obviously not meant to be there and when i pulled it off diesel stared coming out of it.  Please excuse my limited mechanical knowledge, but please could someone explain what is/should be going on here? ImageImageImageThanks
Last edited by sauce1001 on 07 May 2022, 18:02, edited 1 time in total.
1990 Multivan 1.9 AAZ
 

jas915
Registered user
Posts: 228
Joined: 08 Oct 2007, 18:27
80-90 Mem No: 6242
Location: Cupar, Fife Scotland

Re: Diesel Injector Querie

Post by jas915 »

Diesel leak off pipe should be attached. Also dont think thats a tdi just lools like a 1.9td
Grey/white high top, AAZ.

Rascal
Registered user
Posts: 249
Joined: 24 Jul 2020, 11:23
80-90 Mem No: 0

Re: Diesel Injector Querie

Post by Rascal »

Also the rubber cap is supposed to be there.. Although it may need replacing by the sounds of it

Timburrows
Registered user
Posts: 303
Joined: 05 Jun 2014, 12:49
80-90 Mem No: 14187
Location: Shipton Under Wychwood

Re: Diesel Injector Querie

Post by Timburrows »

That is an AAZ indirect diesel,a piece of leak back pipe with a bolt will do as a temporary fix till you get the proper one,the injector pump should have a vacuum fuel enrichment devise on it to give more fuel when boosting assuming it has a turbo on it,ALH is a TDI,definitely not that engine,engine code will be on a machined surface,on the block,below the red temperature sensor in the middle picture

sauce1001
Registered user
Posts: 123
Joined: 12 Aug 2006, 03:24
80-90 Mem No: 2816
Location: Leicestershire

Re: Diesel Injector Querie

Post by sauce1001 »

Hi all many thanks for the quick replies.

ID wise all I can see on the block is 028 103 373J which I think is the cylinder head part number? And the figures 8WNO slightly further to the right.

Is my missing part likely to be causing the smoke issues?

Here's a pic of the whole engine bay if someone can say 100% what engine it's got.

Really appreciate the help.  :ok
Image

 
1990 Multivan 1.9 AAZ
 

sauce1001
Registered user
Posts: 123
Joined: 12 Aug 2006, 03:24
80-90 Mem No: 2816
Location: Leicestershire

Re: Diesel Injector Querie

Post by sauce1001 »

Thanks all for the advice, I've now created what I think is a temporary fix with a piece of diesel leak off pipe (pic below).  Can somebody advise if this is ok, but also where should this pipe route to permanently?

Image
1990 Multivan 1.9 AAZ
 

User avatar
Oldiebut goodie
Registered user
Posts: 7264
Joined: 18 Apr 2008, 01:19
80-90 Mem No: 11135
Location: Eastern Angle

Re: Diesel Injector Querie UPDATE

Post by Oldiebut goodie »

It does not go anywhere, it is sealed off with the manky rubber cap that you have taken off that was meant to be there!
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶

sauce1001
Registered user
Posts: 123
Joined: 12 Aug 2006, 03:24
80-90 Mem No: 2816
Location: Leicestershire

Re: Diesel Injector Querie UPDATE

Post by sauce1001 »

Much appreciated! That ropey old cap was leaking and my dodgy creation has cured it  :D  I"ll leave well alone for now!  The van kicks out quite a bit of blue smoke on start up, none when idling and a fair bit when revved. Where would I be best of starting investigations?  Cheers 
1990 Multivan 1.9 AAZ
 

Timburrows
Registered user
Posts: 303
Joined: 05 Jun 2014, 12:49
80-90 Mem No: 14187
Location: Shipton Under Wychwood

Re: Diesel Injector Querie UPDATE

Post by Timburrows »

Blue smoke is usually oil burning,could be oil in the inlet pipe work from worn engine breathing heavily,valve stem oil seals gone hard from old age,turbo seals leaking into air inlet pipes,poor compression not burning the diesel,poor spray patten from warn injectors,timing set incorrectly not burning all the diesel,smoke will smell of diesel not oil diesel.engine identification code is on a machined surface,on the engine block below the red sensor on the water outlet on the cylinder head

jas915
Registered user
Posts: 228
Joined: 08 Oct 2007, 18:27
80-90 Mem No: 6242
Location: Cupar, Fife Scotland

Re: Diesel Injector Querie UPDATE

Post by jas915 »

Yeah blue smoke is oil, on start up normally valve stem seals. Does itsmoke on over run or just when underload. If underload could be turbo leakimg oil.
Over run blue smoke probably steam seals
Grey/white high top, AAZ.

jas915
Registered user
Posts: 228
Joined: 08 Oct 2007, 18:27
80-90 Mem No: 6242
Location: Cupar, Fife Scotland

Re: Diesel Injector Querie UPDATE

Post by jas915 »

Defo a 1.9 aaz td engine
Grey/white high top, AAZ.

sauce1001
Registered user
Posts: 123
Joined: 12 Aug 2006, 03:24
80-90 Mem No: 2816
Location: Leicestershire

Re: Diesel Injector Querie UPDATE

Post by sauce1001 »

Thanks all for the replies.  I'm booking it in with a mechanic to see if I can get to the bottom of the smoke issues, I'll report back when it's been looked at.
:ok
1990 Multivan 1.9 AAZ
 

Post Reply