Non-Starter - About to call the garage!! UPDATE!!
Moderators: User administrators, Moderators
- foxbase
- Registered user
- Posts: 24
- Joined: 12 May 2008, 12:48
- 80-90 Mem No: 5320
- Location: East Manchester
Non-Starter - About to call the garage!! UPDATE!!
Hi all,
I'm a non mechanically minded owner of a 1985 1.9 Westy Hi-top which until two weeks ago was starting like a dream. I've not been running about since October except for starting it every day and going for a little spin to warm her up once a week.
Two weeks ago it failed to start and I quickly appeared to run the battery down as the starter motor ground to a halt!.
I instantly thought I had killed the battery so first tried jump starting it which enabled me to get the starter motor firing again but nothing from the engine...not a peep.
Not being mechanically minded I still suspected the battery because when I disconnected the jump leads the battery was dead and the starter motor again refused to fire.
My limited knowledge enabled me to disconnect HT leads, dizzy cap, rotor arm thingy and leads to the coil... give them a clean and a spray and replace everything. Still nothing. I even tried spraying some damp start down the air-filter (as the previous owner had told me was required on cold mornings).
Since this I have re-charged the battery which seems to be holding its charge again and is allowing me to get the starter motor whirling again.
Now I'm stuck... AFAIK the engine is fine (was two weeks ago) and AFAI-CAN-TELL the battery/starter motor is fine... what is in the middle????
Be gentle please - if only I can go to the garage with a little confidence in what I'm talking about I'll be most grateful.
Also - I'd like to know how you get the battery out of the van? pushing the seat forward allows access but the seat mounting tray doesn't push far enough forward to enable the battery to pass.
Foxy
I'm a non mechanically minded owner of a 1985 1.9 Westy Hi-top which until two weeks ago was starting like a dream. I've not been running about since October except for starting it every day and going for a little spin to warm her up once a week.
Two weeks ago it failed to start and I quickly appeared to run the battery down as the starter motor ground to a halt!.
I instantly thought I had killed the battery so first tried jump starting it which enabled me to get the starter motor firing again but nothing from the engine...not a peep.
Not being mechanically minded I still suspected the battery because when I disconnected the jump leads the battery was dead and the starter motor again refused to fire.
My limited knowledge enabled me to disconnect HT leads, dizzy cap, rotor arm thingy and leads to the coil... give them a clean and a spray and replace everything. Still nothing. I even tried spraying some damp start down the air-filter (as the previous owner had told me was required on cold mornings).
Since this I have re-charged the battery which seems to be holding its charge again and is allowing me to get the starter motor whirling again.
Now I'm stuck... AFAIK the engine is fine (was two weeks ago) and AFAI-CAN-TELL the battery/starter motor is fine... what is in the middle????
Be gentle please - if only I can go to the garage with a little confidence in what I'm talking about I'll be most grateful.
Also - I'd like to know how you get the battery out of the van? pushing the seat forward allows access but the seat mounting tray doesn't push far enough forward to enable the battery to pass.
Foxy
Last edited by foxbase on 28 Feb 2009, 15:10, edited 1 time in total.
f o x b a s e a l p h a
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
- jamesc76
- Registered user
- Posts: 6241
- Joined: 14 Oct 2005, 14:42
- 80-90 Mem No: 1186
- Location: Nottingham
- Contact:
Re: Non-Starter - About to call the garage!!
theres a small lever on the side of the seat that alows you tio move it right forward , as for starting lets start at the bigging when you turn the key to the start possition what happens?????
DJ at Dubdayz Summerfest
Now cutting about in an LT35 MWB
Now cutting about in an LT35 MWB
- foxbase
- Registered user
- Posts: 24
- Joined: 12 May 2008, 12:48
- 80-90 Mem No: 5320
- Location: East Manchester
Re: Non-Starter - About to call the garage!!
I'll look for that lever!
I turn the key to start pos and if battery charged I get the red light on the dash blinking and the voltage gauge rises to 12-15v. If battery dead I get none of the above.
I turn the key to start pos and if battery charged I get the red light on the dash blinking and the voltage gauge rises to 12-15v. If battery dead I get none of the above.
f o x b a s e a l p h a
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
- jamesc76
- Registered user
- Posts: 6241
- Joined: 14 Oct 2005, 14:42
- 80-90 Mem No: 1186
- Location: Nottingham
- Contact:
Re: Non-Starter - About to call the garage!!
No what actuually happens at the engine end!!! ie does it turn over fast slow clunk etc ?
DJ at Dubdayz Summerfest
Now cutting about in an LT35 MWB
Now cutting about in an LT35 MWB
Re: Non-Starter - About to call the garage!!
could be the starter motor is spinning but not engaging the engine.have you another starter you could try...
allowing me to get the starter motor whirling again.
2.1 LPG/Petrol Auto Caravelle
"The difference between genius and stupidity is that genius has its limits"
"The difference between genius and stupidity is that genius has its limits"
- foxbase
- Registered user
- Posts: 24
- Joined: 12 May 2008, 12:48
- 80-90 Mem No: 5320
- Location: East Manchester
Re: Non-Starter - About to call the garage!!
nothing happens at the engine end. Not a peep! No clunking or anything.
no don't have a spare starter motor either... however... the starter motor was replaced last Feb by previous owner because the van wouldn't start after being in storage for a few months. The van isn't stored now but coincidentally the cold snap recently could be a factor?
no don't have a spare starter motor either... however... the starter motor was replaced last Feb by previous owner because the van wouldn't start after being in storage for a few months. The van isn't stored now but coincidentally the cold snap recently could be a factor?
f o x b a s e a l p h a
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
Re: Non-Starter - About to call the garage!!
on the starter motor shaft there is a cog that moves to engage the teeth on the fly wheel when the starter spins.if this is not engaging the teeth.the engine will not turn.
2.1 LPG/Petrol Auto Caravelle
"The difference between genius and stupidity is that genius has its limits"
"The difference between genius and stupidity is that genius has its limits"
- jamesc76
- Registered user
- Posts: 6241
- Joined: 14 Oct 2005, 14:42
- 80-90 Mem No: 1186
- Location: Nottingham
- Contact:
Re: Non-Starter - About to call the garage!!
Disconnet the battery drag your self undeneath and undo the cables on the starter and the earth srtap on the front of the gearbox then clean them right up so there nice and clean and give a decent connection reconnect them all back up nice and tight, then give the starter solaniod a good tap with a hammer then reconnect batter and try again?
DJ at Dubdayz Summerfest
Now cutting about in an LT35 MWB
Now cutting about in an LT35 MWB
- foxbase
- Registered user
- Posts: 24
- Joined: 12 May 2008, 12:48
- 80-90 Mem No: 5320
- Location: East Manchester
Re: Non-Starter - About to call the garage!!
thanks - I'll get the Haynes out and have a look at where the starter is and try what you suggest before calling the dreaded garage!
f o x b a s e a l p h a
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
- jamesc76
- Registered user
- Posts: 6241
- Joined: 14 Oct 2005, 14:42
- 80-90 Mem No: 1186
- Location: Nottingham
- Contact:
Re: Non-Starter - About to call the garage!!
Starter motor is just about inline with the drivers side rear wheel get at it from below, just make sure you desconect the battery first as the big cable going to the starter is perm live and will make you jump if you earth it out !
DJ at Dubdayz Summerfest
Now cutting about in an LT35 MWB
Now cutting about in an LT35 MWB
- kevtherev
- Registered user
- Posts: 18830
- Joined: 23 Oct 2005, 20:13
- 80-90 Mem No: 2264
- Location: Country estate Wolverhampton Actually
Re: Non-Starter - About to call the garage!!
If you have the engine turning over (a woow woow woow sound)
then first stop is spark. take a spark plug out (any plug and rest it against the engine) where you can see the gap in the electrode, get a friend to turn the engine over and watch the gap for a spark. a nice white spark is desirable.
second is fuel
let's see if you have a spark first
then first stop is spark. take a spark plug out (any plug and rest it against the engine) where you can see the gap in the electrode, get a friend to turn the engine over and watch the gap for a spark. a nice white spark is desirable.
second is fuel
let's see if you have a spark first
AGG 2.0L 8V. (Golf GTi MkIII)
- foxbase
- Registered user
- Posts: 24
- Joined: 12 May 2008, 12:48
- 80-90 Mem No: 5320
- Location: East Manchester
Re: Non-Starter - About to call the garage!!
thanks again guys! I won't get to have a look at it until the weekend but will be back here to report my findings.
i thought about fuel actually - it was very low (really low) so thought it might of run out... I put a gallon in so I'm counting out running out of fuel. Whether or not it's getting through is another matter.
You mention the wow wow wow sound of the engine turning over... I'm not sure I'm even getting that. All I'm hearing is the starter motor whirling away and nothing else.
i thought about fuel actually - it was very low (really low) so thought it might of run out... I put a gallon in so I'm counting out running out of fuel. Whether or not it's getting through is another matter.
You mention the wow wow wow sound of the engine turning over... I'm not sure I'm even getting that. All I'm hearing is the starter motor whirling away and nothing else.
f o x b a s e a l p h a
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
- Nicola&Tony
- Registered user
- Posts: 2674
- Joined: 01 Nov 2006, 18:18
- 80-90 Mem No: 3095
- Location: Wallsend, Tyne & Wear
Re: Non-Starter - About to call the garage!!
foxbase wrote: . . . i thought about fuel actually - it was very low (really low) so thought it might of run out... I put a gallon in so I'm counting out running out of fuel.
That doesn't sound promising. Old fuel tanks get rusty inside and bits of rust end up sitting in the bottom of the tank as debris. If you run the fuel tank low, you start disturbing that debris and bits of it get sucked into your fuel hoses and engine. Keep plenty of fuel in the tank to avoid this.
Tony
Looking for: window apertures for side windows, at the back of the van
T25; 1985; RHD; 1.9DG petrol / LPG; white Autosleeper high-top; Looking rusty again!
LT31; 1993; RHD; 2.4L petrol; high-top; diy camper project.
T25; 1985; RHD; 1.9DG petrol / LPG; white Autosleeper high-top; Looking rusty again!
LT31; 1993; RHD; 2.4L petrol; high-top; diy camper project.
- jamesc76
- Registered user
- Posts: 6241
- Joined: 14 Oct 2005, 14:42
- 80-90 Mem No: 1186
- Location: Nottingham
- Contact:
Re: Non-Starter - About to call the garage!!
foxbase wrote:I thought about fuel actually - it was very low (really low) so thought it might of run out... I put a gallon in so I'm counting out running out of fuel. Whether or not it's getting through is another matter.
You mention the wow wow wow sound of the engine turning over... I'm not sure I'm even getting that. All I'm hearing is the starter motor whirling away and nothing else.
Ahhhhhhhhhhhhh were getting some where now! Right you need to clean all the connections bang the starter solanoid like i said before and get some more fuel, more like another 10 ltrs min in the tank then remove the fuel filter bin it and replace it with a new one, you have most likely draged loads of gunk and rubish out the bottom of your tank so even if the starter worked ok the fuel wouldnt get to the carb anyway!
DJ at Dubdayz Summerfest
Now cutting about in an LT35 MWB
Now cutting about in an LT35 MWB
- foxbase
- Registered user
- Posts: 24
- Joined: 12 May 2008, 12:48
- 80-90 Mem No: 5320
- Location: East Manchester
Re: Non-Starter - About to call the garage!!
Okay, first chance I've had to get back to this since posting this a few weeks ago (my dad is here helping me too until tomorrow)
So, we've done this today:
replaced fuel filter (it was full of sh*t as suggested it would be)
replaced plugs
replaced dizzy and rotor
replaced coil
checked fuel pump - fine
cleaned up all the earths we could find
Now here is the odd thing. After replacing all that lot (one at a time) we still got nothing. Out came the Haynes to confirm firing order etc. 1 4 3 2. Confirmed everything was as it should - nothing but a few pops!!
Changed order of plugs on the dizzy to 1 2 3 4 the engine runs but not on tick-over.
My dad thinks its a timing thing now... anyone else have anything they can offer before I get a mobile mechanic out to her??
Thanks in advance
Jason (and his dad)
So, we've done this today:
replaced fuel filter (it was full of sh*t as suggested it would be)
replaced plugs
replaced dizzy and rotor
replaced coil
checked fuel pump - fine
cleaned up all the earths we could find
Now here is the odd thing. After replacing all that lot (one at a time) we still got nothing. Out came the Haynes to confirm firing order etc. 1 4 3 2. Confirmed everything was as it should - nothing but a few pops!!
Changed order of plugs on the dizzy to 1 2 3 4 the engine runs but not on tick-over.
My dad thinks its a timing thing now... anyone else have anything they can offer before I get a mobile mechanic out to her??
Thanks in advance
Jason (and his dad)
f o x b a s e a l p h a
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM
1985 Westy Joker Hi-top 1.9
LIVING THE DREAM