Strange LPG issue, cutting out after a good run.

LPG, Bio Diesel, Hydrogen, Fuel Cell Questions and Answers last answered over 2 years ago.
You may also want to visit the 80-90 Wiki(pedia) for a more structured index of T25 repair, maintenance, technical and ownership topics.

Moderators: User administrators, Moderators

Locked
User avatar
The_blue
Registered user
Posts: 310
Joined: 22 Feb 2007, 16:01
80-90 Mem No: 3484
Location: Mansfield ish.

Strange LPG issue, cutting out after a good run.

Post by The_blue »

If i go on a good, fast run for a length of time (5mins plus) then pull up at a junction the van stalls or has no power for 1-2 seconds. after that it's fine. If i'm cruising around town it never does it.

Has anyone got any ideas? It must be starved of fuel or flooded i recon. But which and what to do?
Joined club Talbot!

User avatar
dugcati
Registered user
Posts: 1983
Joined: 15 Aug 2007, 18:23
80-90 Mem No: 3825
Location: Debris
Contact:

Re: Strange LPG issue, cutting out after a good run.

Post by dugcati »

vapouriser freezing up? Steve the gas god will be along soon enough to lay words of wisdom :ok 8)
It is by will alone that I set my 'van' in motion!

User avatar
steve8090
R.I.P.
Posts: 861
Joined: 07 Oct 2005, 16:21
80-90 Mem No: 2
Location: Member No.2 Club founder North Wales
Contact:

Re: Strange LPG issue, cutting out after a good run.

Post by steve8090 »

Yes could be vaporiser freezing, who's system is it, usual cause of this symptom is too much gas in the cylinders, power valve too far open or rich mixture, engine cannot breath properly, suggest you take it back to the installer to check out. If its a new system and you are still running it in ie you've done less than a thousand miles then expect this sort of thing, too many peeps expect these systems to run perfect from the word go, they don't, they have to settle and will need adjusting after 6-800 miles then it may need another tweek after that to get it perfect, a lot also miss out the annual service, more fool them, the system will run quite happily until it clogs up or something fails due to contamination.
Steve Shaw
Club80-90 Founder Member
Image
Full Service, LPG conversions, Security and Camper Accessories.
see http://www.gasure.co.uk for full details.
01244 659740

User avatar
The_blue
Registered user
Posts: 310
Joined: 22 Feb 2007, 16:01
80-90 Mem No: 3484
Location: Mansfield ish.

Re: Strange LPG issue, cutting out after a good run.

Post by The_blue »

Thanks guys! I'm very new to the LPG game.


Unknown fit on a new to me van. :(

The vaporiser has a hot water feed, I've just replaced the pipe as it was peeing out. Shouldn't that stop the freeze?

What CO should i be aiming for at idle and high idle? I've got an old analyzer. I'll stick it on and come back with the readings as it stands.

It's a 1980, 2 litre 4 pot LT35 if that matters.

I'll grab a couple of photos of the setup. tonight :)
Joined club Talbot!

User avatar
The_blue
Registered user
Posts: 310
Joined: 22 Feb 2007, 16:01
80-90 Mem No: 3484
Location: Mansfield ish.

Re: Strange LPG issue, cutting out after a good run.

Post by The_blue »

The unit was way over fueling.

the CO was off the chart on high revs, idle was 5%. Ended up turning the power valve down about 1 1/2 turns to get 3.5% high revs and 2.5 idle.

runs fine now and no cutting out.

vaporiser is toasty hot :)
Joined club Talbot!

User avatar
The_blue
Registered user
Posts: 310
Joined: 22 Feb 2007, 16:01
80-90 Mem No: 3484
Location: Mansfield ish.

Re: Strange LPG issue, cutting out after a good run.

Post by The_blue »

Finally remembered the pictures!


If you could shed any light on the make etc it would be appreciated :)

Image

Image

Image
Joined club Talbot!

Locked