i just replaced an altnator and now have B.O.D on the hipressure switch
well i only have the one ,, oil filter one not connected
van is 1980 but diesel conversion 1y
everfy thing was ok till altnator swap ,,when i fitted new alt the voltage reg was iffy and was overcharging at first then not atall brought back and replaced now works ok ..but buzzer and light on ,,is it alt issue or coinsdence and issue at dash
buzzer/altnator
Moderators: User administrators, Moderators
-
- Registered user
- Posts: 360
- Joined: 28 Apr 2010, 00:41
- 80-90 Mem No: 7974
- Location: Dublin..Eire
buzzer/altnator
1989 1y powered panel van camper
1980 1y powerd project
http://www.eireball.com/" onclick="window.open(this.href);return false;
1980 1y powerd project
http://www.eireball.com/" onclick="window.open(this.href);return false;
- AngeloEvs
- Registered user
- Posts: 1345
- Joined: 22 Nov 2007, 19:22
- 80-90 Mem No: 4709
- Location: Upwell, Norfolk
Re: buzzer/altnator
If your van is a 1980 then I cannot quite see how you could interface a DOPS oil pressure system to what is a much earlier loom which does not have the RPM signal wire or the extra oil pressure wire. The DOPS system is designed to function with two oil pressure switches and fitted to later dashboards that have an horizontal multi connector.
You could try linking the wire that goes to the oil pressure switch to chassis earth and see if it cures the problem or disconnect it - what type of oil pressure is fitted, normally open or normally closed? But, based on what you describe, more information is needed regards any changes made to the original wiring and wether a later dashboard has been fitted.
You could try linking the wire that goes to the oil pressure switch to chassis earth and see if it cures the problem or disconnect it - what type of oil pressure is fitted, normally open or normally closed? But, based on what you describe, more information is needed regards any changes made to the original wiring and wether a later dashboard has been fitted.
1987 DG Karisma LPG with remodelled interior
-
- Registered user
- Posts: 360
- Joined: 28 Apr 2010, 00:41
- 80-90 Mem No: 7974
- Location: Dublin..Eire
Re: buzzer/altnator
looks like the dash and whole loom was changed over too
my other van 89 diesel og ky now 1y looks very alike but not excatly the same
this is all was grand till alt changed
they both have the sensors (black normally open) on the head and on the filter housing but on both the one at filter no connected
i swapped the sensors from other van that did not cure it
my other van 89 diesel og ky now 1y looks very alike but not excatly the same
this is all was grand till alt changed
they both have the sensors (black normally open) on the head and on the filter housing but on both the one at filter no connected
i swapped the sensors from other van that did not cure it
1989 1y powered panel van camper
1980 1y powerd project
http://www.eireball.com/" onclick="window.open(this.href);return false;
1980 1y powerd project
http://www.eireball.com/" onclick="window.open(this.href);return false;
- Mocki
- Membership Admin
- Posts: 16980
- Joined: 29 Sep 2005, 09:27
- 80-90 Mem No: 428
- Location: Mansfield Notts
- Contact:
Re: buzzer/altnator
You changed alternator, check that the "W" connection is good , that is where the BoD gets the Rev details from .
Steve
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
- AngeloEvs
- Registered user
- Posts: 1345
- Joined: 22 Nov 2007, 19:22
- 80-90 Mem No: 4709
- Location: Upwell, Norfolk
Re: buzzer/altnator
Easy to determine if it is an alternator issue, check the W connection as advised by Mocki or just put the original one back on as it is not too difficult to do.
The high oil pressure switch is normally open and the 0.3 bar lower oil pressure switch is normally closed, you can emulate the correct operating condition by connecting the wire (yellow) that goes to the high oil pressure switch to chassis and disconnect the blue/black wire that would normally go to the low oil pressure switch.
The high oil pressure switch is normally open and the 0.3 bar lower oil pressure switch is normally closed, you can emulate the correct operating condition by connecting the wire (yellow) that goes to the high oil pressure switch to chassis and disconnect the blue/black wire that would normally go to the low oil pressure switch.
1987 DG Karisma LPG with remodelled interior
-
- Registered user
- Posts: 360
- Joined: 28 Apr 2010, 00:41
- 80-90 Mem No: 7974
- Location: Dublin..Eire
Re: buzzer/altnator
altnator is brand new suppose w trminal could be shagged
the old alt went in the bin how can i check w tremnal ,, i can swap altnator from one van too other i suppose
the old alt went in the bin how can i check w tremnal ,, i can swap altnator from one van too other i suppose
1989 1y powered panel van camper
1980 1y powerd project
http://www.eireball.com/" onclick="window.open(this.href);return false;
1980 1y powerd project
http://www.eireball.com/" onclick="window.open(this.href);return false;