Hope someone can help me out (again), I have square headlights playing up! When I switch to main beam the rhs inner lamp doesn’t come on and the outer goes out completely. I have checked the bulbs, the fuses and cleaned up the earth terminal behind the fuses. I don’t seem to be getting any power to the terminal that links the two lamps at the rear of the unit The wiring disappears inside the loom and don’t really want to cut it all open if I can help it!
Is there a relay somewhere that could be playing up??
Cheers folks
Square lights.
Moderators: User administrators, Moderators
- Mocki
- Membership Admin
- Posts: 16982
- Joined: 29 Sep 2005, 09:27
- 80-90 Mem No: 428
- Location: Mansfield Notts
- Contact:
Re: Square lights.
From original there is no relay , but it maybe there has been a relay added as a upgrade in the recent years .
However , if you are getting power to the headlights at all, it won’t be the relay if it’s there , it will be either dirty connections , a broken wire or poor earths from your description I think
Add new separate earths to the headlights , direct to the van body next to the headlights would be my first steps anyway , you can never have enough good earth connections
However , if you are getting power to the headlights at all, it won’t be the relay if it’s there , it will be either dirty connections , a broken wire or poor earths from your description I think
Add new separate earths to the headlights , direct to the van body next to the headlights would be my first steps anyway , you can never have enough good earth connections
Steve
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
-
- Trader
- Posts: 2593
- Joined: 27 May 2009, 18:56
- 80-90 Mem No: 16628
- Location: hayling island
Re: Square lights.
Sounds most likely to be an earth issue
Re: Square lights.
Thank you both for that. The earth wiring to the bulb at the connector is showing good continuity so I don`t think its an earth issue??
Could the ignition switch be the source as read on various posts? Again, low beam fine but ALL lights fail when switching to high beam on the offside lights and the little blue dashboard light has also stopped working.
Bit stumped
Could the ignition switch be the source as read on various posts? Again, low beam fine but ALL lights fail when switching to high beam on the offside lights and the little blue dashboard light has also stopped working.
Bit stumped
- Mocki
- Membership Admin
- Posts: 16982
- Joined: 29 Sep 2005, 09:27
- 80-90 Mem No: 428
- Location: Mansfield Notts
- Contact:
Re: Square lights.
The dash tell tale is directly run from that one actual headlight , so if that headlight isn’t working the dash tell tale won’t
I still suggest it’s a earth issue , did you test it under load ? A poor connection often looks ok with a meter, until it’s under load
Simplest way to prove the point is to add a extra earth direct from the bulb holder to the van body onto a good clean point , even to the screw that holds the headlight bracket to the body would do .
I still suggest it’s a earth issue , did you test it under load ? A poor connection often looks ok with a meter, until it’s under load
Simplest way to prove the point is to add a extra earth direct from the bulb holder to the van body onto a good clean point , even to the screw that holds the headlight bracket to the body would do .
Steve
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
Re: Square lights.
Many thanks for advice, but unfortunately adding the extra earth as you suggested had no effect.
Still in the dark literally and metaphorically !!
Still in the dark literally and metaphorically !!
-
- Trader
- Posts: 2593
- Joined: 27 May 2009, 18:56
- 80-90 Mem No: 16628
- Location: hayling island
Re: Square lights.
Are they factory fitted ? I still think it’s an earth issue , pull a wire off so only one lights operating, what happens?