L shaped pipe from water pump to thermostat; 1987 T25 DG, purchased from J K's. and difficult to fit. Had to cut away metal to get heater hose take off thro. Pipe is too short so the rubber elbow [pipe to thermostat] is now not long enough to fit the pipe clamps. Awaiting reply from JK.
Any suggestions welcome.? Quickest solution is to obtain a longer elbow but from where?
PS. Just seen on ebay 38mm i/d silicone elbow hose, with 150mm legs, for vehicles. That should solve the problem. JK will probably say send it back which means taking it off, packing it up etc. Blow that.
Will invoice JK for cost of hose.
L shaped pipe
Moderators: User administrators, Moderators
-
- Registered user
- Posts: 647
- Joined: 27 May 2007, 20:48
- 80-90 Mem No: 875
- Location: Weald, Kent
L shaped pipe
1987/8 Autosleeper, 1.9dg (Automatic) hightop. Petrol/ LPG
Re: L shaped pipe
Moral of the story here is don't buy from JK.
Just the same with Britpart for Land Rovers,
Bloody Rubbish!
Just the same with Britpart for Land Rovers,
Bloody Rubbish!
1984 Caravelle 1.9 DG 34 DAT
2002 Audi TT 225 BAM.
2002 Audi TT 225 BAM.
- Oldiebut goodie
- Registered user
- Posts: 7264
- Joined: 18 Apr 2008, 01:19
- 80-90 Mem No: 11135
- Location: Eastern Angle
Re: L shaped pipe
I had that with VW commercial with a hose that didn't fit correctly even though it was the correct part number, so anyone can get it wrong. ( JK more often than others though )
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶
-
- Registered user
- Posts: 647
- Joined: 27 May 2007, 20:48
- 80-90 Mem No: 875
- Location: Weald, Kent
Re: L shaped pipe
Update.
One of those jobs that if it can go wrong it has ie broken hose clips etc
E mailed JK about 'short pipe' and they did not hesitate to pay for the new rubber elbow required.
One point in their favour.
One of those jobs that if it can go wrong it has ie broken hose clips etc
E mailed JK about 'short pipe' and they did not hesitate to pay for the new rubber elbow required.
One point in their favour.
1987/8 Autosleeper, 1.9dg (Automatic) hightop. Petrol/ LPG
Re: L shaped pipe
In my experience, all aftermarket parts fit badly, from 'just OK' to 'not going to work at all!' Sadly you get what you pay for. Original manufacturer parts if available, are always a lot more expensive and for good reason... they actually fit. Aftermarket manufacturers don't have the big budgets sadly. I have bought parts before which actually don't fit at all and it makes you wonder how the sellers don't just get loads of complaints or even why they still sell the parts??