I have a f reg T25 1.9 water cooled petrol.
I have just had the garage replace the water pump. They are not a VW specialist.
The van was making a grinding noise. I called The AA. He suspected a problem in the flywheel area as he said that was where the noise was.
The garage replaced the water pump and said they couldn't source the metal pipe from the water pump to the right of the engine block
They informed us when it was done that there is a slight water leak but can't see where it is coming from. They suspect the pipes going over the engine on the right as there was water on too of the engine near the spark plugs.
They said to bring it back if it gets worse.
I could not see a water leak.
I had the engine running for over 10 minutes but there was no water leak. I checked all the pipes but nothing.
A week later I then noticed a water leak just above the bolt covering the heat plate the one nearest to the exhaust.
I have tried removing the heat plate but the second bolt won't budge. I have WD40
I have had The AA come out again. He had no luck either. He suspects a coil plug.
I don't want to break the bolt and then need to drill the remainder of the bolt out.
What can I do?
What can it be?
Hopefully not the head gasket.
The water reservoir in the engine compartment was half full. When I topped it up the water was running out about 5 seconds later. It is clear water.
When I was going to get the T25 transported back to the garage then didn't want to take it "they said there was too many problems" I suspect they don't know what they are doing and they did damage the metal pipe.
Water leak on VW T25
Moderators: User administrators, Moderators
- Mocki
- Membership Admin
- Posts: 16982
- Joined: 29 Sep 2005, 09:27
- 80-90 Mem No: 428
- Location: Mansfield Notts
- Contact:
Re: Water leak on VW T25
Ok, for us to help you here we will need more details ..... we need pictures of what you are describing to avoid confusion and incorrect advice .
if you add your rough location and the details of your van to your profile it will help save added questions
( you can access your profile details by hovering your mouse over your username up in the top right of the forum )
By the sounds of your description you are talking about the m8x8 bolts that hold the push rod covers onto the heads
steel bolts into alloy , warm the engine up and the alloy will expand faster than the bolts , they wil Come undone
I wouldn’t suggest taking the van back to that garage anyway .
if you add your rough location and the details of your van to your profile it will help save added questions
( you can access your profile details by hovering your mouse over your username up in the top right of the forum )
By the sounds of your description you are talking about the m8x8 bolts that hold the push rod covers onto the heads
steel bolts into alloy , warm the engine up and the alloy will expand faster than the bolts , they wil Come undone
I wouldn’t suggest taking the van back to that garage anyway .
Steve
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
-
- Registered user
- Posts: 1830
- Joined: 16 Sep 2013, 17:19
- 80-90 Mem No: 13596
- Location: Hampshire
Re: Water leak on VW T25
Just to add to MOCKI information, WD40 is only a water dispersant, see if you can get hold of some PLUS GAS, readily available in most outlets and recommended for stuck bolts etc before you start undoing things.
1984 Campervan 1.9DG Petrol WBX
- jrt
- Registered user
- Posts: 3419
- Joined: 01 Oct 2011, 15:53
- 80-90 Mem No: 10288
- Location: East Cheshire
Re: Water leak on VW T25
Contact the garage and tell them again what has happened,although it sounds like they’re clueless. Any idea why they needed to replace the pipe, was it leaking when you had the grinding noise? Where are you , might be worth asking on here for a local vw knowledgeable garage. Definitely post up some pics.
David.
David.
the future is unwritten