My petrol tank has been leaking for some time now but only when I fill it right up. If I fill till the pump clicks off, I got a run of fuel under the van which by the time I had done a mile or so stopped. I had assumed it was the rubber grommets on the breathers and the filler neck so I have just taken the tank out. I love the way on the YouTube videos they say just lean in and 'pop' the breathers out of the tank! Ha ha! Not a chance, but I did manage to get them out after dropping the tank a little. Disappointingly, all the rubbers look OK. So does the tank. No signs of rust or damage anywhere. The only thing I can see are some slight stain marks around the large grommet for the filler neck so I assume it was leaking from here? Is this a common spot for a leak?
I have some pictures but I have no idea how to attach them!!
Leaking Petrol Tank
Moderators: User administrators, Moderators
- Mocki
- Membership Admin
- Posts: 16979
- Joined: 29 Sep 2005, 09:27
- 80-90 Mem No: 428
- Location: Mansfield Notts
- Contact:
Re: Leaking Petrol Tank
Yes, the filler rubber is a very common place for a leak .
there are two different sizes of filler pipe , early is metal and bigger , late is smaller and plastic .
Brickwerks say they have both in stock , https://www.brickwerks.co.uk/catalogsea ... &x=33&y=17
al so check it isn’t the actual filler pipe
adding pictures is soo easy now
there are two different sizes of filler pipe , early is metal and bigger , late is smaller and plastic .
Brickwerks say they have both in stock , https://www.brickwerks.co.uk/catalogsea ... &x=33&y=17
al so check it isn’t the actual filler pipe
adding pictures is soo easy now
Steve
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
Re: Leaking Petrol Tank
You are right! So here are the pictures with the staining marks evident. I have the right seal for the filler neck and all seems good. The breather pipe flexibles were all pretty perished too but I think that would just give a smell of petrol and not a leak!
Re: Leaking Petrol Tank
So on closer inspection I think the sender unit seal was leaking. I always got petrol dripping from the rear edge of the tank and I think after cleaning the tan, these stain marks tell the story!!
Re: Leaking Petrol Tank
I replaced my tank and when refitted also had a leak when tank full. The memory of fitting it was so painfull I’ve not taken it off to see where leak is coming from. I just under fill .
Enjoy the fitting .... at the time I did mine I saw a thread where someone had got rid of the shreks ears and used jubilee clips.
Good luck and hope you have small hands and long arms
Sent from my iPad using Tapatalk
Enjoy the fitting .... at the time I did mine I saw a thread where someone had got rid of the shreks ears and used jubilee clips.
Good luck and hope you have small hands and long arms
Sent from my iPad using Tapatalk
1991 Auto Sleeper Trident High Top
Water Cooled 1.9 Petrol
Water Cooled 1.9 Petrol