High temp 1.9 dg
Replies: 22
by
mark »
06 Sep 2022, 20:57
Hiya
Had an issue on the way to whitby, flashing light and temp up and over 3/4 of gauge yesterday.
Had a look today.. coolant in the rad no air...
22 Replies
9337 Views
Last post by maxstu
03 Nov 2023, 22:54
JX fuel filter clamp
Replies: 5
by
Rdav1s »
27 Oct 2023, 10:32
Hi all,
Does anyone have, or know where I can get a fuel filter clamp for my 88 jx diesel syncro.
I ordered a petrol one by mistake as it looked...
5 Replies
2285 Views
Last post by ZsZ
03 Nov 2023, 07:04
stalling.
Replies: 1
by
HighgateT25 »
02 Nov 2023, 16:21
Hi All,
I bought a 1981 T25 Campervan in the summer. It wasn’t running the greatest but seemed to just be a carb issue. It just kept stalling at...
1 Replies
1758 Views
Last post by cotswoldstony
03 Nov 2023, 01:29
Engine/gearbox swap
Replies: 2
by
kentishvanman »
30 Oct 2023, 12:05
Currently run on my 1.9 water cooled and lpg when you can find a garage. No problems but did think about swapping engine and gearbox for something...
2 Replies
1993 Views
Last post by Porkscratching
30 Oct 2023, 18:26
Gearbox linkage boot?
Replies: 5
by
Shinnster »
08 Oct 2023, 14:06
Hi all,
just had the van MOT'd and was advised to change out this worn boot / gaiter that is by the gearbox.
can anyone tell me the exact name of...
5 Replies
2659 Views
Last post by ajsimmo
29 Oct 2023, 17:29
Engine stalling
Replies: 3
by
Freddievan »
08 Oct 2023, 20:24
Engine needed to be turned 2 or 3 times as the van has been stood for a few days. Once it started it sounded fine. However, half a mile down the...
3 Replies
2150 Views
Last post by JeffRoo
24 Oct 2023, 18:19
Power Steering Question
Replies: 4
by
Porkscratching »
23 Oct 2023, 15:44
Sounds like the fluid is low. Wouldn't hurt to drain what's in it and refill with fresh ATF (automatic transmission fluid) and check the pipes for...
4 Replies
2354 Views
Last post by multisi
24 Oct 2023, 08:06
2 Replies
1905 Views
Last post by Gunter98
22 Oct 2023, 15:39
Cold start cable routing
Replies: 3
by
chalkywoods »
22 Oct 2023, 12:04
The fuel pump on my AAZ fitted by previous owner has a cold start lever but it has never been hooked up. I've got all the parts but it's not obvious...
3 Replies
2134 Views
Last post by chalkywoods
22 Oct 2023, 12:47
Propane tank overfill
Replies: 2
by
Oxonomy »
21 Oct 2023, 07:58
I'm in the United States but own an European version 1989 T3 Westfalia. Recently when I filled the propane tank it apparently overfilled and began...
2 Replies
2040 Views
Last post by Porkscratching
21 Oct 2023, 13:35
Drive Belt treatment
Replies: 8
by
kentishvanman »
19 Oct 2023, 18:17
Have a noisy/screeching drive/fan belt. It is a new belt and tensioned 'right up'. All wheels cleaned. Only screeches for about 10/15secs after start...
8 Replies
2865 Views
Last post by ZsZ
21 Oct 2023, 06:08
Replacement pilot fuel/air jet
Replies: 10
by
Jimmucks »
13 Jun 2016, 12:48
Hi, can anyone tell me if it is possible to buy just a pilot jet for a pier burg carb. I'm not too hot on these yet and I'm struggling to find a...
10 Replies
4692 Views
Last post by Bugsted
18 Oct 2023, 20:30
5 Replies
2078 Views
Last post by mioba
18 Oct 2023, 16:25
cylinder block question
Replies: 1
by
Lio »
17 Oct 2023, 16:54
Hello everybody,
Is the cylinder block for a JX engine (1.6 turbo D) the same than for the non turbo engine ?
I just found out that my cylinder block...
1 Replies
1829 Views
Last post by davidoft1
17 Oct 2023, 21:04
CV boot replacement
Replies: 19
by
kit »
31 May 2016, 23:00
Hi I can't find anywhere on Wiki that shows CV boot replacement, does anyone know of any guide thanks?
19 Replies
7213 Views
Last post by Robsey
17 Oct 2023, 18:57
Radiator cowl
Replies: 2
by
T25Colin »
16 Sep 2023, 22:25
Back from the hols in France (after the frantic alternator change that meant we lost a night) and the van has decided to let the radiator go! For...
2 Replies
1437 Views
Last post by T25Colin
16 Oct 2023, 21:18
4 Replies
1563 Views
Last post by aec
16 Oct 2023, 17:15
coolant levels,
Replies: 5
by
syncro4us »
14 Oct 2023, 15:42
Have been running our rebuilt 2.1 engine for some time with over 2000 KM on the clock so its well run in, so this summer took it to the Pyrenees and...
5 Replies
1325 Views
Last post by Stesaw
16 Oct 2023, 13:30
Carburettor flooding
Replies: 13
by
Brenty »
14 Oct 2023, 18:40
Hi, first posting on the site. Jumped into my 1984 T25 last weekend and it was a no starter.
The carburettor was flooding- so start- then loads of...
13 Replies
1387 Views
Last post by Brenty
15 Oct 2023, 19:26
Valve Springs
Replies: 7
by
Mick.source »
01 Oct 2023, 12:07
Well i finally found the problem with my 1986 westfalia t25 jx camper, which had a rough idle and smoked under load, after removing the head i found...
7 Replies
1149 Views
Last post by lefty67
13 Oct 2023, 18:43
1 Replies
720 Views
Last post by sarran1955
13 Oct 2023, 01:20
Clutch lever
Replies: 2
by
Rjduncanuk »
09 Oct 2023, 08:09
Hi guys, please could anyone tell me if the clutch arm is moving enough? I'm having trouble with selecting gears. The van has been stood for over 6...
2 Replies
673 Views
Last post by Rjduncanuk
09 Oct 2023, 14:03
Brake Hydraulic failure
Replies: 10
by
garyd »
07 Oct 2023, 13:59
My son has just had a weird brake hydraulic failure on his van which we can't get to the bottom of. It is a 1990 2wd van with the 1.9 DG engine.
On...
10 Replies
1162 Views
Last post by multisi
08 Oct 2023, 14:45
Automatic Drive Shaft Seal Replacement
Replies: 1
by
maxstu »
29 Sep 2023, 08:25
Is it the same replacement procedure as manual seals?
Also, the plastic plate. Are they the same for auto and manual. I can't find any listed for...
1 Replies
573 Views
Last post by maxstu
06 Oct 2023, 13:34
Emissions not failure
Replies: 7
by
matthew13 »
03 Oct 2023, 21:01
Hi all. 1983 2ltr cu engine petrol van. Took it for an mot today and it failed on emissions. Anyone got any tips to low the emissions?
7 Replies
787 Views
Last post by lefty67
05 Oct 2023, 14:29
2 Replies
282 Views
Last post by lefty67
05 Oct 2023, 09:48
coolant issue
Replies: 5
by
Lio »
11 Aug 2023, 12:59
Hello,
I did some search on this forum but did not find the exact same issue that I am facing.
I have a turbo D / JX engine from 1987, and that has...
5 Replies
494 Views
Last post by Lio
03 Oct 2023, 18:15
Dellorto 36 install
Replies: 2
by
chrisc23 »
07 Sep 2023, 18:00
Hi guys I’m sort of new here although I have been sneaking around for a couple of years now and generally finding what I need from the search...
2 Replies
290 Views
Last post by PetenAli
01 Oct 2023, 19:29
Diesel Injector pump leak jx
Replies: 11
by
Cecil »
04 Sep 2023, 21:35
I have a fuel leak that is dripping off the bottom of the support bracket on the end of the injection pump just to the right of the bolt head. I have...
11 Replies
688 Views
Last post by Cecil
01 Oct 2023, 06:16
Carb rebuilders
Replies: 4
by
Elsaetka »
29 Sep 2023, 04:13
Hi
Can anyone recommend a quality / reliable Pierburg carb rebuilder for my late 1.9 DG transporter. As per forum advice I was going with Bromyard...
4 Replies
489 Views
Last post by 300CE
29 Sep 2023, 21:14
Engine number confusion
Replies: 24
by
Biggy »
15 Aug 2023, 20:10
Hi Everyone,
I need a bit of help identifying my engine. I was under the impression I had a 1.6D CS, but after trying to find the engine number to...
24 Replies
3018 Views
Last post by ZsZ
29 Sep 2023, 13:13
1 Replies
580 Views
Last post by silverbullet
29 Sep 2023, 12:49
Which Exhaust 1983 Watercooled 1.9
Replies: 3
by
makebigplans »
28 Sep 2023, 13:47
Ok, so it seems our exhaust needs some love. In fact it pretty much needs replacing due to the dreaded rust and terrible use of gun gum, however I'm...
3 Replies
250 Views
Last post by ajsimmo
28 Sep 2023, 15:04
R9 fuel hose inner lining blocking hose?
Replies: 9
by
aec »
24 Sep 2023, 12:54
After 5 years off the road and a lot of very slow DIY repairs my van (1.9DG) passed it's MOT last week. Hurrah! My joy was short lived though, on...
9 Replies
1294 Views
Last post by aec
28 Sep 2023, 10:56
Repeated Head Gasket failure
Replies: 10
by
Rich75 »
31 Jan 2023, 14:04
Hi
So, about 3 years ago I had a recon engine fitted to my 1986 1.9DG T25. It was fine and then started leaking - back to the garage that fitted the...
10 Replies
1317 Views
Last post by silverbullet
25 Sep 2023, 19:51
6 Replies
469 Views
Last post by grace72
24 Sep 2023, 14:50
What engine and carb do I have
Replies: 10
by
Raynsford5 »
19 Sep 2023, 06:23
Hi all having bought our first money pit a beautiful red and white T3/T25 i have come to a self conclusion the previous owners may have installed a...
10 Replies
683 Views
Last post by hubcap61
21 Sep 2023, 08:32
Moutning bolt on carb loose/stripped
Replies: 4
by
VrindaVan »
17 Sep 2023, 04:01
Hey y’all,
I just noticed that the front mounting bolt for my solex 34 pict 4 carburettor was loose as I could even wiggle it with my hand alittle,...
4 Replies
357 Views
Last post by VrindaVan
18 Sep 2023, 12:06
Lost nut
Replies: 6
by
Raynsford5 »
14 Sep 2023, 07:54
Hi all please help needed, this week I decided to renew the pushrod seals on our T3, which appears to be a 1700 T2 engine anyway while removing the...
6 Replies
341 Views
Last post by Raynsford5
17 Sep 2023, 15:44
Brakes jammed on then released
Replies: 3
by
jacko1967 »
17 Sep 2023, 07:47
Morning all
a bit of a strange one yesterday I had been driving for 2 hrs and I came to some traffic lights there was a bit of a thump and the...
3 Replies
285 Views
Last post by Robsey
17 Sep 2023, 10:44
84 1.6D stripped head for injector
Replies: 20
by
Paul773car »
08 Sep 2023, 12:06
Afternoon all, im having a very bad day.
I few weeks back i noticed i was getting blow by past one of my injectors. I ordered a new seal and the...
20 Replies
984 Views
Last post by davidoft1
16 Sep 2023, 07:42
2 liter CU Fan Housing removal
Replies: 2
by
Old Gitt »
11 Sep 2023, 14:22
I have being trying to replace my engine Mounts and struggling to remove the Fan Housing, I have removed the three bolts in the center but it will...
2 Replies
203 Views
Last post by Rosie n' Jim
15 Sep 2023, 19:25
Dipstick length
Replies: 7
by
CameronT25 »
26 Aug 2021, 13:22
Hi, I'm having no luck finding a dipstick for my 1980 T25 2.0 air-cooled engine. Can anyone who has this engine do me a huge favour and measure the...
7 Replies
620 Views
Last post by VrindaVan
15 Sep 2023, 13:18
Mystery copper pipe…
Replies: 9
by
kinger462 »
06 Sep 2023, 10:56
Greetings everyone,
I’m sure this is a stupid question so please excuse me… I’m new at this stuff… but does anyone know what this copper pipe is,...
9 Replies
1231 Views
Last post by kinger462
14 Sep 2023, 15:12
2 Replies
225 Views
Last post by aknapper
11 Sep 2023, 08:20
1980 drive shaft length
Replies: 2
by
keith2 »
05 Sep 2023, 21:28
Hi, could anyone confirm the drive shaft lengths on a 1980 CU engined manual van?
Thanks
2 Replies
217 Views
Last post by keith2
07 Sep 2023, 19:57
3 Replies
294 Views
Last post by aknapper
07 Sep 2023, 13:32
in which Vans did the CT engine come?
Replies: 2
by
VrindaVan »
06 Sep 2023, 16:33
Hey y’all,
I was just curious, did the 1600 CT engine ever come out the production in camper vans and buses or only in the panel van models?
Big...
2 Replies
211 Views
Last post by VrindaVan
06 Sep 2023, 21:40
Hose list??
Replies: 3
by
DJKING360 »
05 Sep 2023, 15:58
I’m hoping that someone has done this before I have to start a spreadsheet.
But does anyone have a list of all replacement hoses for 1.9wbx DG?...
3 Replies
248 Views
Last post by DJKING360
06 Sep 2023, 07:24
DELL'ORTO DRLA 36 > 2.0 CU
Replies: 1
by
batgins »
13 Jul 2020, 07:23
Any advice on the initial setting to start adjusting carburation setting on a pair of drla 36 on a rebuilt 2 liter cu?
I found quite different...
1 Replies
938 Views
Last post by chrisc23
05 Sep 2023, 20:28
Forum permissions
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot post attachments in this forum