Club 80-90 Forums

Was the JX fitted to any other vehicle other than the T25 or is there another engine code that will drop straight in?

Hi, Van is 1.6TD T25 D reg. I have had the top and bottom of the engine rebuilt and its cost £1500 but still it smokes when warm and on idle. Starts fine when cold but not when hot. Garage that took my money MG Raw at Lincoln is now saying they have no idea what the problem is. They are suggesting t...

Please can someone tell me where the heater matrix air intake is on the T25. I have been having problem getting cold air and found the 2 side vent pipes connected to the wrong outlet port but still seem to have hot air all the time. It does vary from warm to hot with the control.

Where is the fresh air intake for the heater matrix? Once we get going the van always seems to be blowing warm air. The control works and changes it from roasting to cool but still we are to hot. The side vents dont work and I found they were attached to the blanked off side output and I can't route...

My T25 1.6TD starts fine and ticks over initially but when its been cruising for a while and you slow down it will stall between gear changes. Even when you re start it it is not happy ideling. Any ideas please

I have built the inside of the van ( 1986 T25 High top) using another old van but where does the gas bottle go and what size is it?

Hi,

Please could someone give me a fuse list for D reg T25 1.6TD desiel? I have a power drain somewhere (and a temp gauage that goes to max as soon as engine started) and need to try and trace the source.

Thanks - Andy Greene

Someone fitted a Golf engine I belive to the van I bought and have left the original injector pump on which menas it has an extra bit on top with a vacume pipe going down to the manifold joing just where the oil pipe goes out to the turbo. Unfortunatly becase of the extra bit on top the whole thing ...

Thanks for advice. I tried checking some bits today and the wiring is a mess of scotch clips and loose wires

T25 wiring problems - Just bought my first VW camper. 1987 1.6TD T25. glow plug light comes on and goes off after a few seconds as it shoud but once the van is started the light flashes permanently. Also the engine temp gauge goes up in steps once ignition is on to full scale deflection. Haynes say ...